NSC E

Size: px

Start display at page:

Download "NSC 952221E451001 1"

符兼鄂
7 years ago
Views:

1 行精類行年年行旅理參理林理利年年

2 NSC E

3 Effects of physico-chemical properties of buckwheat and adlay on post-expansion and glass transition of extruded pellets (pellets) (expansion ratio, ER) - - (Modified Rapid Visco Analysis) L 41.7± ± ± ºC ± ± a/b (pasting temperature)(75.5±0.2ºc) ( 70.8±0.6ºC and 69.0±0.3ºC) (R=0.39) (normalized holding strength, nhs, holding strength 1st cycle / final viscosity) (R 2 ) 0.78 (nhs, [holding strength 1st cycle - holding strength 2nd cycle ] / final viscosity) nhs R 2 =0.92 (peak time)

6 40 a/b 60 3035 (pasting temperature)(75.5±0.2ºc) ( 70.8±0.6ºC and 69.0±0.3ºC) (R=0.

4 Abstract The purpose of this research was to investigate the influence of rheological properties of buckwheat and adlay on expansion properties of their products. Therefore, a prediction model of expansion of pellets were also established and become the core platform for developing functional snack foods. The results showed both adlay and buckwheat pellets had profound enzymatic browning reaction. L values of adlay and buckwheat pellets were 41.7±5.7 and 48.1±2.3, while the value of pellets made with waxy rice was 77.4±2.6. However, pellets made with adlay and buckwheat were darker than waxy rice. Increasing toasting temperature (T temp.) resulted in the decreasement of bulk density. The higher the T temp., the bigger the ER of products was. The ERs of adlay and buckwheat pellets toasted at 300ºC were smaller than waxy rice, and it took 30~40sec for the pellets to reach the plateau or maximum ER before degraded by heat. The addition of 50% waxy rice flour to adlay or buckwheat pellets could raise their ERs from 2.5±0.7 to 3.6±0.6, and reduce the hardness of products significantly, but improve their crispness. The a/b values increased and Maillard reaction occurred obviously while toasting time (T time) was longer than 40sec. At T time over 60sec, heat degradation of pellets started and their colors became darkening. Therefore, the T time of 30~35sec was regarded as suitable to get a better ER and lesser degradation of functional ingredients. In this report, Modified Rapid Visco Analysis was used to measure the viscosities of samples by two continuous heat-hold-cool temp. cycles. It also showed the pasting temp. (PT) of adlay flour (75.5±0.2ºC) was higher then buckwheat and waxy rice (70.8±0.6ºC and 69.0±0.3ºC, respectively), but there was no good linear relationship between PT and ER (R 2 =0.39). However, ER increased with normalized holding strength (nhs), which was defined as holding strength in the first cycle (HS 1 ) divided by final viscosity (FV), more significantly than HS 1 or FV. The R 2 between ER and nhs was about The correlation between ER and nhs, which was defined as HS 1 minus HS 2 and then divided by FV, was more significant (R 2 =0.92) than correlation between ER and nhs. But it was found that the R 2 between peak time and ER was about 0.94, which was the best one. This research provided valuable information for prediction of ERs and future development of functional snack foods. Keywords: adlay, buckwheat, expansion ratio, Rapid Visco Analysis, functional snack foods. 3

The results showed both adlay and buckwheat pellets had profound enzymatic browning reaction. L values of adlay and buckwheat pellets were 41.7±5.7 and 48.1±2.

5 (common buckwheatfagopyrium esculentum Moench) (tatary buckwheat Fagopyrium. tataricum Gaertn) ( ) ( ) (Pomeranz,1983) 香苷 (rutin) (quercetin) (flavanoids) (Pomeranz Robbinas, 1972) (Sun Ho, 2005.) (Oomah Mazza, 1996) (Tomotake, 2000.) (Prestamo, 2003) (Kawa, 2003.) (Kim, 2003.) (Li Zhang, 2001.) ( ) Mariotti (2005) 11.0 (5.36.3) (8.9) (, 2001) (buckwheat) (Polygonaceae) (Fagopyrium) 4

Robbinas, 1972) (Sun Ho, 2005.) (Oomah Mazza, 1996) (Tomotake, 2000.

6 (adlay job s tear) (pellets) (Gramineae) (Coix lachryma-jobi L. var. ma-yuen Stapf) ( ) 69 (, 1994) (coixenolide) (Ukita Tanimura, 1961.) Otsuk (1988) (, 1996, 2000.) (, pellet ( ) 1998) Chung (Harper, (1988) 1981) Chen and Yeh, 2001 ( ) pellet pellet pellet (, 1994) glass transition temperaturet g (2004) state diagram

7 ) (94 I ) 2. (1) Lightness (L)a b (2) (Bulk density) (3) (Rapid (pellets) Visco Analyzer, RVA TM, Australia) - - (4) (pellets) ±5ºC (, Taichung I) (5) (, Taichung I) (, Taichung Waxy 70) ( (, pellets) 77.4±2.6 L 41.7± ±2.3 6

Visco Analyzer, RVA TM, Australia) - - (4) (pellets) 23 1.

8 (PT) ( 1 ABW (75.5±0.2ºC) (PV) ) ºC 519±33cPs (69.0±0.3ºC) PV (3107±36cPs) PT 70.8±0.6ºC (PT) ( 2) (ER) (R 2 =0.39)( 300ºC 5) (holding strength 1st cycle, HS 1 ) 300ºC (final viscosity, FV) 3040 (normalized holding ( 2A) strength, nhs) 1 / final viscosity nhs 2.5± ±0.6( 2A 2B) (R 2 ) 0.78( 6) HS 1 HS 2 FV 40 a/b (nhs) 7 nhs (3) 4 nhs 50 (AW) (0.92) (Peak Time) 0.94 (8) (PTime) (PTime) R nhs RVA (nHS) (nHS) R RVA TM (RVA TM general pasting model) - (Peak Time) nhs 7

viscosity nhs 2.5±0.7 3.6±0.6( 2A 2B) (R 2 ) 0.78( 6) HS 1 HS 2 FV 40 a/b (nhs) 7 nhs (3) 4 nhs 50 (AW) (0.92) (Peak Time) 0.

9 DMA 1. ( 1) ( 1 2 2A2B 3 4 ) 3. ( 3) 4. (R 2 ) 0.92~0.94( 5678) RVA (1) Chen, C. M., and Yeh, A. I Effect of amylose content on expansion of extruded rice pellet. Cereal Chem. 78: Chung, B. S., Suzuki, H., Hayakawa, S., Kim, J. H. and Nishizawa, Y Studies on the plasma cholesterol-lowering component in Coix. Nippon Shokuhin Kogyo Gakkaishi. 35(9): Harper, J. M Extrusion of foods. Vol. I&II. CRC Press, Florida. Kawa, J. M., Taylor, C. G. and Przybylski, R Buckwheat concentrate reduces serum glucose in Streptozotocin-diabetic rats. J. Agr. Food Chem. 51(25): Kim, C. D., Lee, W.-K., No, K.-O., Park, S.-K., Lee, M.-H., Lim, S. R. and Roh, S.-S Anti-allergic action of buckwheat (Fagopyrum esculentum Moench) grain extract. International Immunopharmacology 3: Li, S. and Zhang, Q. H Advances in the development of functional foods from buckwheat. Critical reviews in Food Science and Nutrition 41(6): Mariotti, M. Alamprese, C., Pagani, M. A. and Lucisano, M Effect of puffing on ultrastructure and physical characteristics of cereal grains and flours. J. Cereal Sci. 43: (Accepted 28 June 2005) Oomah, B. D. and Mazza, G Flavonoids and antioxidative activities in buckwheat. J. of Agri. Food Chem. 44: Otsuka, H., Hirai, Y., Nagao, T. and Yamaski, K Anti-inflammatory activity of benzoxazinoids from roots of Coix lachryma-jobi L. var. ma-yuen. J.Natu. Prod. 51: Pomeranz,Y Buckwheat: structure, composition, and utilization. CRC Critical Review in Food Science and Nutrition. 19: Pomeranz, Y. and Robbinas, G. S Amino-acid composition of buckwheat. J. Agric. Food Chem. 20: Prestamo, G., Pedrazuela, A., Penas, E., Lasuncion, M. A. and Arroyo, G Role of buckwheat diet on rats as prebiotic and healthy food. Nutrition Research 23: Sun, T. and Ho, C.-T Antioxidant activities of buckwheat extracts. Food Chem. 90: Tomotake, H., Shimaoka, I., Kayashita, J. and Yokoyama, F A buckwheat protein product suppresses gallstone formation and plasma cholesterol more strongly than soy protein isolate in hamsters. The Journal of Nutrition 130(7): Ukita, T. and Tanimura, A Studies on anti-tumor components in the seeds of Coix Lachryma- jobi L. var. ma-yuen (Roman.) Stapf. I. Isolation and anti-tumor activity of coixenolide. Chem. Pharm. Bull. 9:

35(9): 618-623. Harper, J. M. 1981. Extrusion of foods. Vol. I&II. CRC Press, Florida. Kawa, J. M., Taylor, C. G. and Przybylski, R 2003.

10 1 ( ) 2 Table 1 Composition of pellets and their colors. Table 2 Effects of toasting temp. on BD&ER of ABW. Composition (%) Parameters of Color Toasting Temperature Adl Bkw Wxr L a b Toasting 150 o C 225 o C 300 o C Time A ± ± ±2.7 (sec) BD: Bulk Density (g/cm 3 ) B ± ± ±0.1 [ER]: Expansion Ratio W ± ± ± ± ± ± AW ± ± ±1.0 [ 1.0±0.1 ] [ 2.3±0.9] [ 3.2±0.3 ] BW ± ± ± ± ± ± AB ± ± ±1.8 [ 1.8±0.7 ] [ 2.6±0.2 ] [ 3.2±0.3 ] ABW ± ± ± ± ± ± Adl: Adlay, Bkw: Buckwheat, Wxr: Waxy rice [ 2.2±0.1 ] [ 2.6±0.1 ] [ 3.7±0.3 ] Expansion Ratio Pellet A Pellet B Pellet W Expansion Ratio Pellet AW Pellet BW Pellet AB Pellet ABW Toasting Time (sec) Toasting Time (sec) 2A (A) (B) (W) 2B (Wxr) (Adl) (Bkw) Figure 2A. Differences of ERs between pellet A, B&W. Figure 2B. Effects of Wxr addition on ER of Adl & Bkw. 1.3 a / b Toasting Time (sec) 3 a/b Figure 3. Relationships between a/b and toasting time. 4 (AW) Figure 4. Pellet AW at various toasting time. 9

1±2.3 8.2±0.1 13.9±0.1 [ER]: Expansion Ratio W -- -- 100 77.4±2.6-0.3±0.6 13.0±0.8 1.26±0.07 0.65±0.32 0.41±0.04 30 AW 50 -- 50 43.6±0.9 10.0±1.1 17.1±1.0 [ 1.0±0.1 ] [ 2.3±0.9] [ 3.2±0.3 ] BW -- 50 50 50.

11 3 RVA Table 3. Expansion ratio, peak time, pasting temperature and viscosities of various flours analyzed by modified RVA. Flour PV P Time PT HS 1 HS 2 Breakdown MV FV Setback1 Setback2 ER A B W AW BW AB WAB PV: Peak Viscosity HS 1 : Holding Strength in the 1st cycle. MV: Midle Viscosity Setback1: MV - HS 1 = Setback1 P Time: Peak Time HS 2 : Holding Strength in the 2nd cycle. FV: Final Viscosity Setback2: MV - PV = Setback2 PT: Pasting Time Breakdown: PV - HS 1 = Breakdown ER: Expansion Ratio of products 5 6 (nhs) Figure 5. The relationship between PT and ER. Figure 6. The relationship between nhs and ER. nhs) 8 Figure 7. The relationship between nhs and ER. Figure 8. The relationship between P Time and ER. 10

MV: Midle Viscosity Setback1: MV - HS 1 = Setback1 P Time: Peak Time HS 2 : Holding Strength in the 2nd cycle.

Microsoft Word - A200812-1992.doc

Microsoft Word - A200812-1992.doc 1 长期遮荫对小麦籽粒淀粉理化特性的影响张传辉, 姜东, 戴廷波, 荆奇, 曹卫星南京农业大学, 农业部作物生长调控重点开放实验室, 南京 (2195) E-mail: jiangd@njau.edu.cn 摘要 : 揭示了长期遮荫对小麦籽粒淀粉理化特性的影响选