FA-8553 Intel Pentium M /Intel Celeron M Embedded CPU Board USER S MANUAL (V1.0) 健昇科技股份有限公司 JS AUTOMATION CORP. 台北縣汐止市中興路 100 號 6 樓 6F,No.100,Chungshin Rd. Shitsu, Taipei, Taiwan, R.O.C. TEL:886-2-2647-6936 FAX:886-2-2647-6940 http://www.automation.com.tw E-mail:control.cards@automation.com.tw - 1 -
CONTENTS 1. Forward...3 2. Features...4 3. Specifications...5 4. Jumper and Connector Locations / Dimensions...6 4.1 Jumper and Connector Locations...6 4.2 Dimensions...7 5. Connector and Jumper setting...8 5.1 CN1/CN2:COM1/COM2 PORT...8 5.2 CN3: VGA PORT...8 5.3 CN4: KB/MS Mini Din PORT...8 5.4 CN5/CN6/CN16:USB Connector...8 5.5 CN7:VGA Connector...9 5.6 CN8:Audio Connector...9 5.7 CN9/CN12/CN23/CN24: COM3/COM4/COM5/COM6...9 5.8 CN10/CN11:USB PORT...9 5.9 CN13/CN14:Inverter Connector...10 5.10 CN15: LVDS2 Connector /CN17:LVDS1 Connector...10 5.11 CN18:GPIO Connector...10 5.12 CN19:Temperature Sensor...10 5.13 CN20: Power Output Connector...11 5.14 CN21: LED Output Connector...11 5.15 CN22 : SMBUS Connector...11 5.16 CN25:Power Input (12V)...11 5.17 CN26: Power LED Connector...11 5.18 CN27: IDE Active LED...11 5.19 CN28: Compact Flash Socket...11 5.20 CN29: K/B Lock Connector...11 5.21 IDE1: Prinary HDD interface /IDE2:Secondary HDD interface...12 5.22 LPT1: PRINT Connector...13 5.23 FAN1/FAN2: CPU FAN...13 5.24 JP1/JP5: LVDS Voltage...13 5.25 JP2: CPU VCCP Select...13 5.26 JP3: CPU VCCA Select...13 5.27 JP4: COMS Setup...14 5.28 SW1: Reset Button...14 5.29 SW2: Power On Button...14 6. Ordering Information...15-2 -
1. Forward Thank you for your selection of FA-8553 cpu card. Any comment is welcome, please visit our website: www.automation.com.tw for the up to date information. - 3 -
2. Features Support On-board 479 ufc-bga ULV Intel Celeron M or Intel Celeron M or 479 ufc-pga Intel Pentium M to 1GHz+ On Board 512MB DDR Memory Dual Independent LVDS Display High Performance Intel Ethernet (10Base-T/100Base-TX or Gigabit Ethernet) 6 USB, 6 COM, Multi-IO Supported Type II Compact Flash for Embedded OS (Option) Compact 5.25 ESB Form Factor, Low Profile Design 8 bit TTL IO Wide Temperature Embedded SBC (-20 to +60 degree C ) 12V DC only - 4 -
3. Specifications CPU : Intel Pentium / Celeron M System Chipset : Intel 855GM/852GM System Memory : On Board DDR Memory (512MB) Display : Intel GMCH Integrated Graphics Controller with 64MB sharing memory. SSD : Compact Flash Connector (under secondary master device) Ethernet : ICH4 embedded MAC with Intel 82562EZ PHY 10/100 Ethernet Controller or Intel 82540EM Gigabit LAN Chipset Audio : 18 Bit Audio Codec Chip AC 97 2.3 complaint interface Support Line_in / Line_out / Mic_in Daughter Board 2Watts Amplifier (optional) I/O : USB Port : 6, USB 2.0 ports Serial Port : 6, high speed 16550 fast UART serial ports with 12V/5V Power IDE Interface : 2, Ultra ATA100 interface FDD Interface : 1, supports 1.44/2.88MB and 3-mode floppy drive Printer Port : On board printer port with SPP/EPP/ECP mode Keyboard / Mouse : 2, PS/2 TTL IO : 8, TTL IO ports PCI Slot Extension : 32 bit PCI slot for Extension H/W Monitoring : Winbond 83627HF support 7 voltage, 3 temperature and 2 fan-speed control Watchdog Timer : Software Programmable Watchdog Timer with 1sec/minute timeout intervals range from 1 to 255 seconds/minutes Real Time Clock : 256 bytes CMOS RAM built-in ICH4 chipset Backup by non-rechargeable Lithium cell battery Power Requirement : 12V Single Power Required Temperature : Operating: -20 to +60 degree C Relative Humidity : Operating: 10% to 80% (non-condensing) - 5 -
4. Jumper and Connector Locations / Dimensions 4.1 Jumper and Connector Locations - 6 -
4.2 Dimensions - 7 -
5. Connector and Jumper setting 5.1 CN1/CN2:COM1/COM2 PORT 1 DCD 6 DSR 2 RX 7 RTS 3 TX 8 CTS 4 DTR 9 RI 5 GND 5.2 CN3: VGA PORT 1 R 2 G 3 B 4 NC 5 GND 6 GND 7 GND 8 GND 9 VCC 10 GND 11 NC 12 V_DATA 13 HSYNC 14 VSYNC 15 V_CLK 5.3 CN4: KB/MS Mini Din PORT 1 KDATA 2 MDATA 3 KMGND 4 KMVCC 5 KCLK 6 MCLK 7 GND 8 GND 9 GND 5.4 CN5/CN6/CN16:USB Connector 1 5VSB 2 GND 3 DATA 4 DATA+ 5 DATA+ 6 DATA 7 GND 8 5VSB - 8 -
5.5 CN7:VGA Connector 1 R 2 VCC 3 G 4 GND 5 B 6 NC 7 HSYNC 8 V_DATA 9 VSYNC 10 V_CLK 5.6 CN8:Audio Connector 1 IN_L 2 AGND 3 AGND 4 IN_R 5 OUT_L 6 AGND 7 AGND 8 OUT_R 9 MIC IN 10 AGND 5.7 CN9/CN12/CN23/CN24: COM3/COM4/COM5/COM6 1 DCD 2 DSR 3 RX 4 RTS 5 TX 6 CTS 7 DTR 8 RI 9 GND 10 NC 5.8 CN10/CN11:USB PORT 1 5VSB 5 GND 2 DATA 6 DATA+ 3 DATA+ 7 DATA 4 GND 8 5VSB G1 GND G2 GND G3 GND G4 GND - 9 -
5.9 CN13/CN14:Inverter Connector 1 P12V 2 GND 3 VCC 4 GND 5 ON/OFF 5.10 CN15: LVDS2 Connector /CN17:LVDS1 Connector 1 LCD+ 2 LCD+ 3 YAP0 4 YAM0 5 YAP1 6 YAM1 7 YAP2 8 YAM2 9 YAP3 10 YAM3 11 CLKAP 12 CLKAM 13 NC 14 NC 15 GND 16 GND 17 YBP0 18 YBM0 19 YBP1 20 YBM1 21 YBP2 22 YBM2 23 YBP3 24 YBM3 25 CLKBP 26 CLKBM 27 (DDCPCLK) 28 (DDCPDATA) 29 GND 30 GND 5.11 CN18:GPIO Connector 1 GPIP4 2 GPOP0 3 GPIP5 4 GPOP1 5 GPIP6 6 GPOP2 7 GPIP7 8 GPOP3 9 GND 10 VCC 5.12 CN19:Temperature Sensor 1 Sensor+ 2 GND - 10 -
5.13 CN20: Power Output Connector 1 VCC 2 GND 5.14 CN21: LED Output Connector 1 IDE LED 2 VCC3 3 Power LED 4 GND 5.15 CN22 : SMBUS Connector 5.16 CN25:Power Input (12V) 1 VIN 2 VIN 3 GND 4 GND 5.17 CN26: Power LED Connector 1 LED+ 2 LED- 5.18 CN27: IDE Active LED 1 LED+ 2 LED- 5.19 CN28: Compact Flash Socket (Refer to the specification of CF card) 5.20 CN29: K/B Lock Connector 1 Keylock 2 GND - 11 -
5.21 IDE1: Prinary HDD interface /IDE2:Secondary HDD interface 1 LDERST 2 GND 3 PD7 4 PD8 5 PD6 6 PD9 7 PD5 8 PD10 9 PD4 10 PD11 11 PD3 12 PD12 13 PD2 14 PD13 15 PD1 16 PD14 17 PD0 18 PD15 19 GND 20 NC 21 PDREQ 22 GND 23 PIOW 24 GND 25 PIOR 26 GND 27 PHDRDY 28 GND 29 PDACK 30 GND 31 IRQ14 32 NC 33 PDA1 34 NC 35 PDA0 36 PDA2 37 PDCS1 38 PDCS3 39 HD_LED1 40 GND 41 VCC 42 VCC 43 GND 44 GND - 12 -
5.22 LPT1: PRINT Connector 1 STB 2 AFD 3 D0 4 ERR 5 D1 6 INIT 7 D2 8 SLIN 9 D3 10 GND 11 D4 12 GND 13 D5 14 GND 15 D6 16 GND 17 D7 18 GND 19 ACK 20 GND 21 BUSY 22 GND 23 PE 24 GND 25 SLCT 26 GND 5.23 FAN1/FAN2: CPU FAN 1 GND 2 12V 3 Sense 5.24 JP1/JP5: LVDS Voltage 1-2 3.3V 2-3 5V 5.25 JP2: CPU VCCP Select 1-2 Banias 2-3 Dothan 5.26 JP3: CPU VCCA Select 1-2 Banias 2-3 Dothan - 13 -
5.27 JP4: COMS Setup Short Open Clear Normal 5.28 SW1: Reset Button ON OFF Reset Normal 5.29 SW2: Power On Button ON OFF PWR ON/OFF Normal - 14 -
6. Ordering Information PRODUCT JD50FA8553 JD50FA8553B DESCRIPTIONS FA-8553A Celeron M 1GHz 852GM FA-8553B Celeron M 600MHz 852GM - 15 -