报告编号 :WSCT1405000115BS 日期 :2014 年 6 月 12 日第 1 页共 5 页 申请商 Applicant :TORNADO SCIENCE GROUPS LIMITED 飓风科技集团有限公司 地址 Address :1-1-402,NanKai Industrial Zone, Tianjin, P.R.China 天津市南开区南开工业园 1-1-402 以下检测之样品是由委托方所提供及确认 : Report on the submitted sample said to be: 样品名称 Sample name : 锂离子电池 Li-ion Battery 型号 Model 供应商 Supplier 制造厂 Manufacturer :TDP-12V12AH :TORNADO SCIENCE GROUPS LIMITED. :TORNADO SCIENCE GROUPS LIMITED. 接收样品日期 Date of sample received : May.28. 2014 测试时间 Date(s) of test : Jun.5. 2014~ Jun.8. 2014 测试要求 Test Requested 结果 Result 1 关于危险货物运输的建议书 - 规章范本 ST/SG/AC.10/1/Rev.17 188 款 United nations recommendations on the TRANSPORT OF DANGEROUS GOODS model Regulations (17 th Rev. Edition) special provisions 188. Pass/ 合格 ****** 更多详细信息请查阅下页 FOR FURTHER DETAILS, PLEASE REFER TO THE FOLLOWING PAGE(S)****** 测试 Tested by: 审核 Reviewed by: Davis Yang 工程师 Engineer Rain huang 实验室经理 Lab Manager 批准 Approved by: Wang Fengbing 授权签字人 Approved Signatory
报告编号 :WSCT1405000115BS 日期 :2014 年 6 月 12 日第 2 页共 5 页 1. 基本信息 Basic information 样品名称 Sample name 标称电压 Nominal voltage 内含电池数量 Battery number 包装件重量 Packaging weight 外包装 Outer packing 包装件电池净重 Net quantity of batteries per package 试验项目 Test item 试验结论 Test conclusion 锂离子电池型号规格 Lithium ion Battery Type TDP-12V12AH 3.7V 额定容量 Rated capacity 12A 144Wh 18/Packing 商标 Trade mark ENERBYTE 30.5Kg 包装件尺寸 (L*W*T) Packaging dimensions (360*360*360)mm 瓦楞纸箱内包装 Corrugated cate Inside packing 纸盒 Paper box 1.65Kg/Packing 1.2 米跌落测试 1.2m drop test 被测试包装件能够承受 1.2m 跌落试验, 其内装的电池没有破损, 没有产生导致内装电 池的直接接触的移动及内容物泄漏, 测试合格 The tested package is capable of withstanding a 1.2m drop test in any orientation without damage to cells or batteries contained therein,without shifting of the contents so as to allow battery to battery or cell to cell contact and without release of contents. the test passed.
报告编号 :WSCT1405000115BS 日期 :2014 年 6 月 12 日第 3 页共 5 页 2. 1.2 米跌落测试 1.2m drop test 环境条件 Environmental conditions: 温度 Temperature (20±5), 相对湿度 R.H. (40-70)% 测试设备 Name of Equipment: 跌落试验机 drop test machine 型号 Model: WSCTBS-012 序号 No. 试验项目 Test item 试验依据 结果 /Result 备注 remark 关于危险货物运输的建议书 - 规章范本 1.2 米跌落测试 ST/SG/AC.10/1/Rev.17 188 款 United nations 1 1.2m drop test recommendations on the TRANSPORT OF DANGEROUS GOODS model Regulations (17th Rev. 合格 /Pass -- Edition) special provisions 188. 跌落方向 Drop position: 跌落方向 Drop position 上面 Top 前面 Front 侧面 Side 棱 Edge 角 Angle 包装状态 Status 合格 /Pass 合格 /Pass 合格 /Pass 合格 /Pass 合格 /Pass 测试要求描述 Testing requirements description: 1) 每个电芯或电池的包装件或者完全包装件必须能承受 1.2 米跌落测试, 每个包装件进行 5 次不同方向的跌落 测试, 而不造成包含在其中的电池或电芯的损坏, 不造成使电池与电池 ( 电芯与电芯 ) 接触的内含物的移动 和内含物的释出 The package of batteries is dropped from 1.2m 5 times per package. Each package is capable of withstanding a 1.2m drop test in any orientation without damage to cells or batteries contained therein, without shifting of the content so as to allow battery to battery(cell to cell) contact and without release of contents. 结论 Conclusion: 包装件通过 1.2m 跌落试验 The package had passed 1.2m drop test.
报告编号 :WSCT1405000115BS 日期 :2014 年 6 月 12 日第 4 页共 5 页 电池 Battery: 样品图片 Photo of the sample 包装件 Package:
报告编号 :WSCT1405000115BS 日期 :2014 年 6 月 12 日第 5 页共 5 页 ****** 报告结束 End of report*****