温 州 森 明 阀 门 管 件 有 限 公 司 Wenzhousenminvalvepipe fittingco.,ltd. 198
www.wz868108.com www.cnsenming.com Sanitary Pumps 卫 生 级 泵 系 列 199
温 州 森 明 阀 门 管 件 有 限 公 司 Wenzhousenminvalvepipe fittingco.,ltd. 卫 生 级 离 心 泵 Sanitary Centrifugal Pumps 应 用 : BAW 离 心 泵 是 一 种 高 效 又 经 济 的 泵, 因 它 既 可 以 满 足 卫 生 级 对 产 品 进 行 柔 和 处 理 的 要 求, 又 具 有 化 学 稳 定 性, 所 以 它 适 用 于 大 部 分 卫 生 行 业 领 域 Application: BAW Centrifugal pump is an efficient and economical pump both due to meeting the requirements of the health and gentle handling of product and to its chemical stability. It is applies to most fieds of the sanitary industry. 设 计 标 准 BAW 离 心 泵 的 基 本 组 成 部 件 包 括 : 一 台 标 准 马 达, 泵 轴, 膨 胀 联 轴 器, 转 接 器, 后 板, 叶 轮, 泵 壳 以 及 轴 封 适 用 卫 生 应 用 的 BAW 离 心 泵 均 有 不 锈 钢 机 壳 护 罩, 用 于 对 马 达 的 保 护, 而 且 每 一 套 完 整 的 BAW 离 心 泵 单 元 均 配 有 四 只 可 以 调 节 式 的 不 锈 钢 支 撑 脚 森 明 生 产 的 BAW 离 心 泵 特 有 的 增 大 出 水 口 和 先 进 的 叶 轮 设 计 可 使 产 品 畅 流 无 阻 同 时 满 足 最 低 的 NPSH 要 求 ( 最 低 的 NPSH 要 求 可 以 减 少 气 蚀 现 象 的 产 生 ) 此 产 品 使 用 CIP( 原 位 清 洗 ) 或 手 动 清 洗, 同 时 在 设 计 中 采 用 了 可 清 洁 轴 封 Design Standards: The basic components of SAW centrifugal pump included: a standard motor, spindle, expansion couplings, converters, backboard, impeller, pump case and shaft seal. BAW centrifugal pumps for sanitary applications have stainless steel case shields for the protection of the Mazda, and each pump unit equipped with a complete set of four stainless steel support can be adjustable feet. SENMING s centrifugal pumps special design of amplifying outlet and advanced impeller allows smooth flow and meets the minimum NPSH requirements (minimum requirements can be reduced NPSH cavitation phenomena occur). This product can be cleaned by CIP or by hand. It also has a cleanable seal. 200
www.wz868108.com www.cnsenming.com 技 术 数 据 功 率 p:2.2kw 流 量 Q:10T/h 扬 程 H:m 最 大 入 口 水 压 :500Kpa(5bar) 温 度 范 围 :-10 C ~ +1 C(EPDM) 噪 音 水 平 ( 距 离 1m 时 ):60 ~ 85dB(A) 双 端 机 械 轴 封 时 入 口 水 压 : 最 大 500Kpa (5Bar); 水 消 耗 量 :0.25-0.5L/h Technical Data: Power:2.2kw Flow:10T/h Lift:M Max inlet pressure:500kpa(5bar) Temperature range:-10 - +1 Noise level(distance of 1 meter):60-85db(a) Double-end mechanical seal inlet pressure:max 500kpa(5Bar);Water consumption:0.25-0.5l/h 材 料 钢 质 部 件 :4/316L 密 封 件 :EPDM 橡 胶 Material: teel part: 4/316L Seal: EPDM 马 达 带 底 座 法 兰 的 电 机, 根 据 IEC 公 制 标 准, 电 压 频 率 50/60Hz 时 2 个 电 极 =00/00rpm 频 率 电 压 与 功 率 (3 相 电 ) 50HZ,220-2V /380-420VY 4KW( 推 荐 ) 60HZ,250-280V /4-480VY 6KW Motor With a basic flange mater, according to IEC metric standard, when the Voltage frequency 50/60Hz,two electrodes is 00/00rpm Frequency, Voltage and Power(3-phase Electricity) 50HZ,220-2V/380-420V 4KW(Recommended) 60HZ,250-280V/4-480VY 6KW 201
温 州 森 明 阀 门 管 件 有 限 公 司 Wenzhousenminvalvepipe fittingco.,ltd. 卫 生 级 离 心 泵 Sanitary Centrifugal Pumps 技 术 参 数 Main Parameter 型 号 Types 数 量 ( 吨 / 小 时 ) Flow(ton/h) 扬 程 ( 米 水 柱 ) Distance (Mwatercolumn) 电 机 功 率 Electricpower 进 出 口 径 Entrance diameter 备 注 Remarks SMH-1.5-14 SMH-3-16 SMH-5-1.5 3 5 14 16 0.5 1.1 1.5 /DN25 /DN32 50/ 32/25 38/32 38/38 SMH-5-32 SMH-10- SMH-10- SMH-15-5 10 10 15 32 2.2 2.2 3 3 50/ 50/ 50/ 50 51/38 51/38 51/38 51 SMH-20- SMH-20- SMH-25-20 4 50 51 20 5.5 50 51 25 4 50/50 51/51 SMH-- SMH-- SMH--60 SMH-35-35 60 5.5 7.5 配 ABB 电 机 ABB Motor SMH-- SMH--45 45 80/65 80/65 76/63 76/63 SMH-50- SMH-80- SMH-80-50 80 80 15 18.5 80/65 100/80 100/80 101.6/76 101.6/76 SMH-100T- SMH-100T-70 SMH-150T- 100 100 150 70 22 33 33 125/100 125/100 150/125 SMH-200T- SMH-200T-70 200 200 70 45 55 150/125 150/125 Note: The speed regulation can adopt stepless speed variator or frequency converter.the range of speed regulation is 200~900rpm. 202
www.wz868108.com www.cnsenming.com 卫 生 级 自 吸 泵 Sanitary Absorb Pump CIP 自 吸 泵, 其 泵 体 部 分 材 料, 均 为 耐 酸 不 锈 钢 制 成 (AISI316), 耐 酸 碱 腐 蚀 特 性, 尤 为 显 著, 符 合 食 品 卫 生 要 求 优 于 离 心 泵 的 特 性, 在 于 能 吸 取 混 有 空 气 或 泡 沫 的 液 体, 甚 至 能 在 只 有 空 气 时, 照 样 自 行 抽 吸, 该 泵 是 容 积 式 泵, 广 泛 用 于 液 位 低 于 泵 的 吸 取 物 料, 如 在 吸 奶 间, 可 将 奶 自 奶 桶 中 吸 出 或 可 在 自 动 CIP 清 洗 系 统 中, 作 为 清 洗 缸 的 回 程 泵, 机 械 密 封 为 内 装 内 流 式, 吸 取 物 料 温 度 不 高 于 100 CIP self-priming pump uses acid resistant stainless steel (AISI 316) as the main material of the pump body, possessing the character of resisting the erosion of acid and alkali and going well with the requirements of food sanitary. The self-priming pump can inhale the liquids with air or foams,and it can also work well even in the condition of only airso it is the capacitive pump with the superior characters than centrifugal pumps. It is broadly used in imbibition when liquid surface is lower than the pump.e.g.it can inhale the milk from the barrel; It can also be used in the CIP as the returning pump for cleaning tank, mechanical sealed as internal flow. The temperature of the absorbing material can not be higher than 100 性 能 Capability 型 号 Types 流 量 Q Q Flow 总 扬 程 H H Total distance 其 中 吸 程 Suction stroke 叶 轮 轮 幅 直 径 Impeller diameter 进 出 口 管 径 Entrance diameter 电 动 机 型 号 Electromotor type 功 率 Power 转 速 Rotating 外 型 尺 寸 ( 长 宽 高 ) Speed Size(L*W*H) 机 器 重 量 Weight 主 要 参 数 Main technical parameter 20T/M T/M T/M 20T T T M M M 5-6M 5-6M 5-6M 192 192 Ø215 63.5/63.5 76/63.5 76/76 M2QA132S4A M2QA132M4A M2QA160SM4A 5.5KW(380V.50HZ) 7.5KW(380V.50HZ) KW(380V.50HZ) 1420r/min 1420r/min 1420r/min 760x320x475 760x320x475 1006x0x600 0kg 6kg 168kg 203