YAS1/D1.2P22 700V 1.2A SSR YAS1/D0.6P22 700V 0.6A SSR 概述 /General Features 光电隔离 / optoelectronic isolation 负载电流最大为 1.2A/Max load 1.2A 高负载耐压 700V/High load voltage 700V 符合 RoHS/RoHS compliant UL E481250 应用 /Applications 家电产品 ( 空调 冰箱 洗衣机微波炉等的风扇 加热 进出水开关等控制 ) Home appliances (air conditioners, microwave ovens, washing machines, personal hygiene systems, refrigerators, fan heaters, inductive heating cooker, and water heaters, etc.) 工业控制 Industrial equipment market. 订货信息 /Ordering Information Part Number Package Marking YAS1/D1.2P22 DIP7 YAS1/D1.2P22 YAS1/D0.6P22 DIP7 YAS1/D0.6P22 极限值 /Absolute Maximum (Ta=25 ) 输入端 /Input 输出端 /Outpu t 特性参数 /Parameter 符号 /Symbol 测试条件 /Test condition 最小值 /Min. 典型值 /Typ. 最大值 /Max. 单位 /Unit 反向电流 /LED reverse I R VR=5V 1 µa 正向电流 / LED forward I F 50 断态泄漏电流 /Output off-state leakage I R VD=700V 1 µa 阻断电压 / Repetitive peak OFF-state voltage V DRM 700 V 额定电流 / ON-state RMS I YAS1/D1.2P22 1200 IF=10 YAS1/D0.6P22 600 12000 浪涌电流 / Surge I YAS1/D1.2P22 50Hz, 1 cycle YAS1/D0.6P22 6000 版权归所有 1
电参数 /Electrical parameter 特性参数 /Parameter 输入端 Input 输出端 Output 符号 /Symbol 测试条件 /Test condition 最小值 /Min. 典型值 /Typ. 最大值 /Max. (Ta=25 ) 单位 /Unit 正向电压 LED forward voltage V F IF=10 1.2 1.3 V 输入电流 * Input Current 额定电流 * ON-state RMS I Vin=14.4 Vd.c,Ri=750Ω 10.0 19.8 I YAS1/D1.2P22 1200 IF=10 YAS1/D0.6P22 600 维持电流 Holding I H 25 浪涌电流 Surge 12000 I YAS1/D1.2P22 50Hz, 1 cycle YAS1/D0.6P22 6000 电压指数上升率 dv/dt dv/dt VDRM=600V*1/ 2 200 V/µs LED 触发电流 * trigger I FT VO=6V,RL=100Ω 4 8 耦合特性 Transfer characteristics 导通电压降 * Output on-state voltage drop 导通时间 Turn on time 关断时间 Turn off time V YAS1/D1.2P22 YAS1/D0.6P22 t on t off IF=10, IL=1200 VD=6V IF=10, IL=600 VD=6V IF=10, VD=6V,RL=100Ω 1.1 2.5 1.1 2.5 V 0.01 0.1 ms 1+1/2cyc le 介质电压 ** I/O Dielectric Strength V ISO Ioff 0.5 4000 V rms 工作温度 Operating temperature T -30 85 ms 储存温度 Store temperature -40 125 备注 : 带 * 参数为关键参数 带 * * 表示在空气中测试不低于 3000, 高于 3000V 请在油中测试 版权归所有 2
外形尺寸 /Outline dimension : 符号最小典型最大符号最小典型最大 A1* 6.13 6.33 6.53 E* 0.34 0.42 0.50 A2 6.22 6.42 6.62 F* 2.54 A3 7.32 7.62 7.92 G 0.25 A4* 8.10 8.40 8.70 H 1.39 1.59 1.79 B1* 9.00 9.20 9.40 I* 3.07 3.27 3.47 B2 9.05 9.25 9.45 R 0.20 C 5.57 M1 10 D 1.52 M2 12 注 1: 未注公差请按 ±0.2; 注 2: 带 * 尺寸为关键尺寸 版权归所有 3
订货信息 /Ordering Information : 订货信息 /Ordering Information 公司商标代号 Company symbol 交流输出型 AC SSR Y AS 1/ D 1.2 P 22 () 封装 Package:1:DIP8;2:SIP4( 单列直插 ) 输入端电流型 Current driving:d 输入电压型 Voltage driving: 05D 5V;12D 12V;24D 24V; 负载电流 Load :0.6 0.6;A1 1A;1.2 1.2A;2 2A; Z: 过零 Zero-cross; P: 调相 Non zero-cross 负载电压 Load voltage:22:220vac;38:380vac 用户特殊编号 Special code 特性曲线 /Characteristic Data: 负载电流与环境温度关系曲线 Load vs. ambient temperature characteristics 版权归所有 4
2. 导通压降 环境温度特性 3.LED 触发电流 环境温度特性 4.LED 导通压降 环境温度特性 5. 导通时间 LED 电流特性 6. 重复峰值关断电流 负载电压 7. 维持电流 温度特性 版权归所有 5
2.* 接通和关断时间关系,Turn on/turn off time 接线图 /Wiring diagram: 注意事项 /Notes a) 工作环境温度超过 25 时请降额使用, 降额曲线参考附件 When ambient temperature is above 25, the load must be reduced. (see Annexes,fig.1) b) 继电器接线时, 务必保证输入端极性的正确, 以免损坏继电器 Ensuring the polarity is correct when connecting the input lines, otherwise the wrong connection will damage the relay. c) 由于 SSR 动作时间很短, 输入端的噪声可能会引起 SSR 误动作, 所以在输入端环境噪声较大时, 应在输入端接 R/C 回路吸收噪声 Since the operate time of the relay is extremely short, any noise toinput terminal will cause malfunction of the SSR, So a RC circuit should be connected to input terminal to absorb the noise in the noisy condition. 版权归所有 6
d) 推荐的使用电路, 输出端的尖峰电压可能会引起 SSR 误动作, 所以请在输出端应加 R/C 回路或压敏电子吸收尖峰电压, 具体见下图 : Below shows a recommend circuit: Please add a RC circuit or varistor on the load side, as noise/surge could damage the unit or cause malfunctions. 关于防静电对策 /Cautions for Static Electricity a. 使用电烙铁时, 对电烙铁前端进行接地 ( 建议使用低电压用的电烙铁 ) When using soldering irons, either use irons with low leakage, or ground the tip of the soldering iron. (Use of low-voltage soldering irons is also recommended.) b. 组装时使用的设备等也应正确地接地 Devices and equipment used in assembly should also be grounded. 关于焊接 /soldering 继电器焊接,260 度情况下焊接时间不能超过 10 秒钟,350 度情况下焊接时间不能超过 5 秒钟 Soldering must be completed within 10 seconds at 260 or within 5 seconds at 350. 版权归所有 7