SOLNOI VLVS direct operated, slide disc single solenoid / dual solenoid 1/4 to 3/8 4/2 Series 342 TURS rass bodied 4/2 slide disc valves, single or dual solenoid, ideally suited to control double acting pneumatic actuators Solenoid valves with integrated pilot and slide disc mechanism irect lift solenoid valves have spring loaded sliding resilients for absolute tight shut-off The solenoid valves do not require a minimum operating pressure The solenoid valves satisfy all relevant irectives NRL ifferential pressure Maximum viscosity Response times 0-9 bar [1 bar = 100ka] 65cST (mm 2 /s) 20-40 ms fluids ( ) temperature range (TS) seal materials ( ) air, inert gas, water, oil -20 to + 70 NR (nitrile) MTRILS IN ONTT WIT LUI ( ) nsure that the compatibility of the fluids in contact with the materials is verified rass body Stainless steel body ody and seat rass ISI 303 SS ore tube Stainless steel Stainless steel ore and plugnut Stainless steel Stainless steel ore spring Stainless steel Stainless steel Sealing NR NR Seat reinforced T reinforced T Slide iscs NR NR Slide cups M M Shading coil opper opper M R L Not vailable Not vailable Not vailable 15,4W-20,0W Low Reduced Medium asic OWR LVLS - cold electrical holding values (watt) SIITIONS operating pressure flow pipe orifice differential (bar) prefix optional solenoids basic coefficient level catalogue size size max. (S) Kv (1) (watt) NM TX / Ix I65 number min. air ( ) 7&9 x d x e mb x mb NT (mm) (m 3 /h) (l/m) ~ = ~ N M V S brass stainless steel Single solenoid 1/4 4,8 0,6 7,5 0 9,0 (2) - 20,0 - - - 342001 342-701 3/8 4,8 0,6 7,5 0 9,0 (2) - 20,0 - - - 342003 342-703 ual solenoid 1/4 4,8 0,6 7,5 0 9,0-15,4 - - - 342020 342-720 3/8 4,8 0,6 7,5 0 9,0-15,4 - - - 342022 342-722 vailable feature - Not available 1) With built-in flow control (suffix M); The flow is 0,38 (m 3 /h) / 6,3 (l/min) and 0,03 bar minimum operating pressure is required (2) Single solenoid 7 bar on water ll leaflets are available on: www.asconumatics.eu 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc I-3-10- 80036-2012/R01
SRIS 342 RIX TL prefix description level 1 2 3 4 5 6 7 L R M xplosionproof - NM 7, 9 - Zinc plated steel conduit - - - - V xplosionproof - NM 7, 9-316 SS conduit - - - - M Waterproof I67 - Metal enclosure (N/I 60079-7+18, 61241-1)* - - - - T Threaded conduit/hole (M20 x 1,5) - - - I S S Intrinsically safe with S coil (N/I 60079-11+26, 61241-11)* - - - - N lameproof - luminium (N/I 60079-1, 60079-31)* - - - V ncapsulated epoxy moulded (N/I 60079-18, 61241-18)* - - - - S Solenoid with spade plug connector (N/I 60730) - - - W Waterproof I67 - Metal enclosure - - - W I S I.S. with Metal I67 enclosure (N/I 60079-11+26, 61241-11)* - - - - W S Waterproof I67-316 SS enclosure - - - W S M Waterproof I67-316 SS enclosure (N/I 60079-7+18, 61241-1)* - - - - W S I S I.S. with 316 SS I67 enclosure (N/I 60079-11+26, 61241-11)* - - - - W S N lameproof - 316 SS (N/I 60079-1, 60079-31)* - - - T Threaded conduit (1/2" NT) - - - lass - attery charging circuit - - - T lass - igh temperature - - - X Other special constructions - - - SUIX TL suffix description level 1 2 3 4 5 L R M M (ethylene-propylene) - - - - R (chloroprene) - - - - N Oxygen service (R (chloroprene)) - - - - N V M (fluoroelastomer) and parts cleaned for oxygen service - - - - V M (fluoroelastomer) - - - - O poxy coating on all external surfaces - - - - ry gas, non-lubricated air construction - - - - Q Long life, quiet operation construction - - - - M Metering device - - - M O ush type manual operator - - - vailable feature vailable feature in only - Not available * TX solenoids are also approved according to N 13463-1 (non electrical valves) ROUT SLTION UI ST 1 Select basic catalogue number, including pipe thread indentification letter. Refer to the specifications table on page 1. xample: 342001 ST 2 Select prefix (combination). Refer to the specifications table on page 1 and the prefix table on page 2, respect the indicated level. xample: NT ST 3 Select suffix (combination) if required. Refer to the suffix table on page 2, respect the indicated level. xample: MS ST 4 Select voltage. Refer to standard voltages on page 3. xample: 24V / 50z ST 5 inal catalogue / ordering number. xample: NT 342001 MS 24V / 50 z ORRIN XMLS VLVS: S 342001 230V / 50 z N 342003 M 110V / 50 z WSN 342-701 24V / 50 z OTIONS & SSORIS catalogue spare part kit no. (1) number ll leaflets are available on: www.asconumatics.eu 3-10-2 mounting bracket no. ~ / = 342001 306191 342003 306191 342020 306193 342022 306193 342-701 310189 342-703 310189 342-720 310191 342-722 310191 (1) Standard prefixes/suffixes are also applicable to kits Mounting holes in body prefix pipe thread basic number ORRIN XMLS KITS: prefix basic number N 306191 306193 (2) 310189 M (2) asic kit number applies to S coil construction 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc suffix voltage suffix 80036-2012/R01
XLNTION O TMRTUR RNS O SOLNOI VLVS Valve temperature range Operator ambient temperature range Total temperature range SRIS 342 The valve temperature range (TS) is determined by the selected seal material, the temperature range for proper operation of the valve and sometimes by the fluid (e.g. steam) The operator ambient temperature range is determined by the selected level and the safety code The temperature range of the complete solenoid valve is determined by the limitations of both temperature ranges above LTRIL RTRISTIS oil insulation class lectrical safety I 335 Standard voltages (~) 24V - 48V - 115V - 230V/50z; Other voltages and 60z are available on request ratings operator ambient electrical replacement coil / kit prefix inrush holding hot/cold temperature enclosure safety code option ~ ~ = range protection ~ = type (2) (V) (V) (W) (W) ( ) (1) (N 60529) 230V/50 z 24V/ asic () S 110,0 23,6 15,4 - -40 to +75 N 60730 I65, moulded 400525-117 - 02 S 240,0 43,0 20,0 - -40 to +75 N 60730 I65, moulded 400525-217 - 01 W/WS 110,0 23,6 15,4 - -40 to +75 N 60730 I67, steel /SS 400505-117 - 06 W/WS 240,0 43,0 20,0 - -40 to +75 N 60730 I67, steel /SS 400505-217 - 05 N/WSN 110,0 23,6 15,4 - -60 to +25/40/60 II2 x d II b T6/T5/T4, II2 x t III b I67, alu./steel 400505-117 - 04 N/WSN 240,0 43,0 20,0 - -60 to +25/40 II2 x d II b T5/T4, II2 x t III b I67, alu./steel 400505-217 - 03 (1) Temperature range can be limited by sealings (3) Multiple coil kits are available under TX/Ix, contact us (2) Refer to the dimensional drawings on page 4 and 5 - Not available LTRIL ONNTIONS prefix connection S spade plug connector with cable gland N175301-803 (ISO 4400) for cables with an outer diameter from 6 to 10 mm W, WS M20 cable gland for cables with an outer diameter from 7 to 12 mm. With an internal and external facility for an earthing or bonding conductor N, WSN 1/2" NT threaded cable entry. nclosures are supplied without cable gland ITIONL OTIONS ompliance with "UL", "S" and other local approvals available on request 1/2" NT (prefix "T") and M20 x 1,5 (prefix "T") conduits (aluminium or 316 SS) available for steel solenoid housing Special moulded-in solid state components for peak voltage suppression and/or rectification (four diode bridge) INSTLLTION Multi language installation/maintenance instructions are included with each valve The solenoid valves can be mounted in any position without affecting operation aution: o not energise both solenoids simultaneously or dual solenoid construction one of the solenoids may be energized momentarily or continuously. Minimum on-time of coil is 0,1 second. Threaded pipe connection identifier is = NT (NSI 1.20.3). eclarations of conformity are available on request ll leaflets are available on: www.asconumatics.eu 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc 3-10-3 80036-2012/R01
SRIS 342 IMNSIONS (mm), WIT (kg) TY 01: TY 02: poxy moulded poxy moulded S: I 335 / ISO 4400 S: I 335 / ISO 4400 342 001 / 003 / -701 / -703 342 020 / 022 / -720 / -722 K L M K L M TY 03: TY 04: luminium, epoxy coated / ISI 316 SS luminium, epoxy coated / ISI 316 SS N / WSN : N/I 60079-1, N/I 60079-31 N / WSN : N/I 60079-1, N/I 60079-31 342 001 / 003 / -701 / -703 342 020 / 022 / -720 / -722 1/2 NT 9 1/2 NT 9 15 15 M5 79 M5 167 TY 05: TY 06: Metal, epoxy coated / ISI 316 SS Metal, epoxy coated / ISI 316 SS W / WS: I 335 W / WS: I 335 342 001 / 003 / -701 / -703 342 020 / 022 / -720 / -722 ll leaflets are available on: www.asconumatics.eu 3-10-4 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc 80036-2012/R01
SRIS 342 IMNSIONS (mm), WIT (kg) type prefix/option level K L M weight 01 S 50 33 64 97 91 56 33 66 24 84 112 115 1,40 kg 02 S 50 33 64 97 91 56 33 66 24 84 112 115 1,80 kg 03 N, WSN 95 33 64 102 54 66 24 112 137 - - - 2,40 kg 04 N, WSN 95 33 64 102 54 66 24 112 222 - - - 3,80 kg 05 W, WS 75 33 64 122 84 66 24 89 116 - - - 1,50 kg 06 V 75 33 64 122 84 66 24 89 178 - - - 2,00 kg STIONL RWIN xecution : ual solenoid xecution : Manual operator (MO) xecution : Metering (M) MOUNTIN ONIURTION 14 24 1/4-20 UN-2 ll leaflets are available on: www.asconumatics.eu 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc 3-10-5 80036-2012/R01
SRIS 342 ll leaflets are available on: www.asconumatics.eu 3-10-6 地址 : 中国 青岛市重庆南路 99 号海尔云街甲 3 号楼 7 网址 :http://www.ivalve.cc mail:sales@ivalve.cc I-03-0010- -- vailability, design and specifications are subject to change without notice. ll rights reserved. 80036-2012/R01