福田零部件图册 (TB454-Q161Y20K) 福田雷沃重工国际贸易有限公司

福田零部件图册 (TB5-QY0K) 福田雷沃重工国际贸易有限公司

目录 CONTENTS 序号 代码 页次 Page QC95T5--0 0.- 机体总成 CYLINDER BLOCK QC95T5--0 0.0- 气缸盖罩总成 CYLINDER HEAD COVER ASSEMBLY 5 QC95T5-- 0.- 正时齿轮室总成 TIMING GEAR CASE ASSEMBLY 7 QC95T5-- 0.- 飞轮壳总成 FLYWHEEL COVER ASSEMBLY 5 QC95T5-- 0.- 高压油管总成 HIGH PRESSURE OIL PIPE ASSEMBLY QC95T5-- 0.- 机油泵总成 OIL PUMP ASSEMBLY 5 7 QC95T5--5 0.5- 呼吸器总成 BREATH ASSEMBLY 7 QC95T5-- 0.- 机油管路总成 OIL CIRCUIT ASSEMBLY 9 9 QC95T5--7 0.7- 水泵风扇总成 -7 WATER PUMP AND FAN ASSEMBLY-7 0 QC95T5-- 0.- 喷油泵 OIL INJECTION PUMP QC95T5--9 0.9- 发电机总成 ALTERNATOR ASSY 5 QC95T5--0 0.- 正时齿轮传动系总成 TIMING GEAR ASSEMBLY- 7 QC95T5--0 0.0- 燃油供给总成 -0 FUEL SUPPLY SYSTEM ASSEMBLY 9 QC95T5-- 0.- 喷油器总成 FUEL INJECTOR ASSEMBLY 5 QC95T5-- 0.- 机油滤清器总成 OIL FILTER ASSEMBLY QC95T5-- 0.- 燃油滤清器总成 - FUEL FILTER ASSEMBLY- 5 7 QC95T5-- 0.- 起动电机总成 STARTING MOTOR ASSEMBLY 7 QC95T5--0 0.- 气缸盖总成 CYLINDER HEAD ASSY 9 9 QC95T5--0 0.- 活塞 连杆总成 PISTONS & CONNECTING RODS 0 QC95T5--05 0.5- 曲轴 飞轮总成 CRANKSHAFT FLYWHEEL ASSEMBLY 5 QC95T5--0 0.- 凸轮轴总成 CAMSHAFT ASSY 7 QC95T5--07 0.7- 油底壳总成 OIL SUMP ASSEMBLY 9 QC95T5--0 0.- 排气管总成 - EXHAUST PIPE ASSEMBLY- 5 QC95T5--09 0.9- 进气管总成 -9 INTAKE PIPE ASSEMBLY-9 5 5 TB00. - 空气滤清系总成 -AIR CLEANER ASSEMBLY 55

目录 CONTENTS 序号 代码 页次 Page TB500.D - 冷却系总成 -COOLING SYSTEM ASSEMBLY 57 7 TB00.0F 0.- 手油门总成 0.-HAND THROTTLE ASSEMBLY 59 TB00.0B 0.- 脚油门总成 0.-FOOT THRORRLE ASSEMBLY 9 TB00.0B 0.- 拉线总成 0.-PULL WIRE ASSEMBLY 0 TB550.. - 离合器总成 -CLUTCH ASSEMBLY 5 TB550..- 离合器总成.-CLUTCH ASSEMBLY 7 TB50..- 离合器操纵机构总成.-CLUTCH CONTROL MECHANISM ASSEMBLY 9 TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 7 TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 7 5 TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 77 TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 7 TB50.-5..5- 前驱动桥总成 -5 FRONT DRIVING AXLE ASSEMBLY-5 5 TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 9 9 TB55..- 前托架总成.-FRONT BRACKET ASSEMBLY 9 0 FT0.F.00 - 前驱动轮总成 -FRONT DRIVING WHEEL ASSEMBLY 9 FT00.F.00 - 后驱动轮总成 -REAR DRIVE WHEEL ASSEMBLY 95 TB00.7A 7.- 变速箱壳体总成 7.-GEARBOX HOUSING ASSEMBLY 97 TB50.7B- 7..- 主变速总成 - MAIN TRANSMISSION ASSEMBLY- 99 TB50.7B- 7..- 主变速总成 - MAIN TRANSMISSION ASSEMBLY- 0 5 TB50.7C- 7.- 变速箱操纵机构总成 7.-GEARBOX CONTROL MECHANISM ASSEMBLY 05 TB50.7C- 7.. 变速箱操纵机构总成 - GEARBOX CONTROL MECHANISM ASSEMBLY- 07 7 TB0.B-..- 后桥中央传动总成 - REAR AXLE CENTRAL TRANSMISSION ASSEMBLY- TB0.B-..- 后桥中央传动总成 - REAR AXLE CENTRAL TRANSMISSION ASSEMBLY- 9 TB55.A.- 差速锁操纵机构总成.-DIFFERENTIAL LOCK CONTROL MECHANISM 5 50 FT00.9.00-9.- 最终传动总成 - 9FINAL TRANSMISSION ASSEMBLY - 7

目录 CONTENTS 序号 代码 页次 Page 5 FT00.9.00-9.- 最终传动总成 - 9FINAL TRANSMISSION ASSEMBLY - 5 TB50.0B- 0.- 全液压转向管路总成 - FULL HYDRAULIC STEERING PIPE ASSEMBLY- 5 5 TB50.0B 0.- 转向器及转向管柱总成 0.-REDIRECTOR OR STEERING COLUMN ASSEMBLY 9 5 TB50.0B- 0.- 全液压转向管路总成 - FULL HYDRAULIC STEERING PIPE ASSEMBLY- 55 TB00.D.- 动力输出齿轮总成.-PTO GEAR ASSEMBLY 5 TB550.A.- 动力输出轴总成.-PTO SHAFT ASSEMBLY 7 57 TB550.D.- 动力输出操纵总成.-PTO CONTROL ASSEMBLY 9 5 TB55.C.- 分动箱箱体总成.-TRANSFER CASE HOUSING ASSEMBLY 59 TB5..- 分动箱传动总成.-TRANSFER CASE TRANSMISSION ASSEMBLY 7 0 TB55.C.- 分动箱操纵总成.-TRANSFER CASE CONTROL ASSEMBLY 9 TB50..- 左制动器总成.-LEFT BRAKE ASSEMBLY 5 TB50..- 右制动器总成.-RIGHT BRAKE ASSEMBLY 5 TB50.-..- 制动器操纵机构总成 - BRAKE CONTROL MECHANISM ASSEMBLY- 55 TB50.-..- 制动器操纵机构总成 - BRAKE CONTROL MECHANISM ASSEMBLY- 57 5 TB00.G - 座椅安装总成 SEAT INSTALLATION ASSEMBLY TB550.5Y 5.- 地板总成 5.-FLOOR ASSEMBLY 7 TB550.5U- 5..- 地板总成 - FLOOR ASSEMBLY- 5 TB550.5U- 5..- 地板总成 - FLOOR ASSEMBLY- 7 9 TB550.5U- 5..-- 地板总成 - FLOOR ASSEMBLY- 9 70 TB00.57B 5.7- 前连接总成 5.7-FRONT CONNECTING ASSEMBLY 7 7 TB00.N - 安全架安装总成 -SAFETY FRAME INSTALLATION ASSEMBLY 7 7 TB00B.7A 7.- 机罩总成 7.-BONNET ASSEMBLY 75 7 TB00B.7 7.- 机罩锁紧装置总成 7.-BONNET LOCKING DEVICE ASSEMBLY 77 7 TB550.77E 7.7- 机罩加长板总成 7.7-BONNET EXTENSION PLATE ASSEMBLY 79 75 TB50.F.- 发动机线束安装总成.-ENGINE HARNESS INSTALLATION ASSEMBLY

目录 CONTENTS 序号 代码 页次 Page 7 TB50.H.- 车身线束安装总成.-BODY HARNESS INSTALLATION ASSEMBLY 77 TB50.B.- 前灯线束安装总成.-FRONT LAMP HARNESS INSTALLATION 5 7 TB500.C.- 后灯线束安装总成.-REAR LAMP HARNESS INSTALLATION ASSEMBLY 7 79 TB50.5A.5- 蓄电池安装总成.5-BATTERY INSTALLATION ASSEMBLY 9 0 TB00.7.7- 组合仪表总成.7-COMBINED INSTRUMENT ASSEMBLY 9 FT00.9.00 9- 工具箱总成 9-TOOL BOX ASSEMBLY 95 TB00.50X 50- 燃油箱装配总成 50-FUEL TANK INSTAllation assembly 97 FT00.5.00 5- 拖挂装置总成 5-TOW EQUIPMENT ASSEMBLY 99 TB50.55A 55.- 提升器装配总成 55.-LIFTER INSTALLATION ASSEMBLY 0 5 TB50.55A- 55.- 提升器装配总成 - LIFTER INSTALLATION ASSEMBLY-7-0 TB50.55C 55.- 提升器操纵机构总成 55.-LIFTER CONTROL MECHANISM ASSEMBLY 07 7 TB50.55A- 55.- 提升器装配总成 - LIFTER INSTALLATION ASSEMBLY-7- TB50.55A- 55.- 提升器装配总成 - LIFTER INSTALLATION ASSEMBLY-7-9 TB50.55A- 55.- 提升器装配总成 - LIFTER INSTALLATION ASSEMBLY- 7 90 TB50.55A-5 55.5- 提升器装配总成 -5 LIFTER INSTALLATION ASSEMBLY-5 9 9 TB50.55A- 55.- 提升器装配总成 - LIFT ASSEMBLY- 9 TB50.55A-7 55.7- 提升器装配总成 -7 LIFT ASSEMBLY-7 5 9 FT500A.5B.00-5.- 悬挂机构总成 - SUSPENSION MECHANISM ASSEMBLY- 9 9 FT500A.5B.00-5.- 悬挂机构总成 - SUSPENSION MECHANISM ASSEMBLY- 95 FT5.5J.00 5- 油泵油管总成 5 9 TB50.5C 5.- 多路阀操纵机构总成 5.-MULTI-WAY VALVE CONTROL MECHANISM 7 97 TB50.5C- 5..- 多路阀操纵机构总成 - MULTI-WAY VALVE CONTROL MECHANISM 9 9 TB50.5C- 5..- 多路阀操纵机构总成 - MULTI-WAY VALVE CONTROL MECHANISM 99 TB50.5C- 5..- 多路阀操纵机构总成 - MULTI-WAY VALVE CONTROL MECHANISM 00 TB00.5A 5.- 单路液压输出总成 5.-SINGLE-WAY HYDRAULIC OUTPUT ASSEMBLY 7

目录 CONTENTS 序号 代码 页次 Page 0 TA00.ZC - 安全带 -SAFETY BELT 9 0 FT0.7A.00 7- 前配重总成 7-FRONT BALLAST ASSEMBLY 5 0 FT00.7B.00 7- 前配重架总成 7-FRONT BALLAST BRACKET ASSEMBLY 5 0 TB00.9 9- 后配重总成 9-REAR BALLAST ASSEMBLY 55 5

QC95T5--0 0.- 机体总成 CYLINDER BLOCK 标号 代号 数量 Quantity 备注 Remark 0 GBT977.-FB00X0X 0500000 090000700 09000000 0500000 内包骨架旋转轴唇形密封螺塞 (ZG/ ) 分油道堵塞凸轮轴后衬套碗形塞 O RING SCREW PLUG PLUG REAR BUSH OF CAMSHAFT BOWL PLUG 5 5 7 0500000 09000000 05000000 095000900 095000000 碗形塞放水阀接管放水开关气缸盖定位套气缸套 BOWL PLUG DRAIN VALVE BLOCK DRAIN SWITCH CYLINDER COVER LOCATING BUSH CYLINDER LINER 9 0 090000000 GBT57-MX0 090000000 0950000500 095000000 气缸盖螺栓 ( 乙 ) 六角头螺栓气缸盖螺栓 ( 甲 ) 缸盖垫机体 CYLINDER COVER () CYLINDER COVER () CYLINDER HEAD GASKET BLOCK 5 5 7. 9 09000000 09500000 GBT57-MX5 095000500/00 09500000 凸轮轴前衬套进水口封板螺栓主轴瓦主轴承盖 FRONT BUSH OR CAMSHAFT WATER INLET SEAL PLATE MAIN BEARING MAIN BEARING COVER 5 0. GBT9-090000500 09000000/00 09500000 090000900 垫圈 凸轮轴中衬套曲轴止推片后主轴承盖主轴承盖螺栓 MIDDLE BUSH OF CAMSHAFT CRANKSHAFT HALFRING REAR MAIN BEARING COVER 0

QC95T5--0 0.- 机体总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark 7 5 5 090000700 GBT97.- 09000000 09000000 090000900 放水阀部件垫圈后油封盖后油封盖后油封盖垫片 DRAIN VALVE BLOCK REAR OIL SEAL COVER REAR OIL SEAL COVER REAR OIL SEAL COVER GASKET 7 9 GBT9.-B0X5 09000000 GBT9.-BX0 圆柱销 碗形塞 圆柱销 PIN BOWL PLUG PIN

5

QC95T5--0 0.0- 气缸盖罩总成 CYLINDER HEAD COVER ASSEMBLY 标号 代号 数量 Quantity 备注 Remark. 090000 090000 0950000 09500000 加油口盖加油口盖垫圈气缸盖罩气缸盖罩密封圈 COVER CAP GASKET CYLINDER HEAD COVER CYLINDER COVER SEAL RING

7

QC95T5-- 0.- 正时齿轮室总成 TIMING GEAR CASE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 0000700 0900000 0900000 00000 000000 盖板齿轮室盖垫片齿轮室盖空气压缩机垫片盖板 COVER PLATE GEAR CHAMBER COVER GASKET COVER,GEAR GASKET COVER PLATE 5 7 GBT7-00 0900000 GBT57-MX0 GBT9.-BX0 09000090 轴承液压泵齿轮六角头螺栓圆柱销定时指针 BEARING HYDRAULIC PUMP GEAR PIN TIMING POINTER 9 0 GBT977.-FB0X0X 000000 GBT9- GBT97.- GBT57-MX5 内包骨架旋转轴唇形密封垫片垫圈 垫圈六角头螺栓 O RING 5 5. GBT70-M GBT97.- 09000500 09000000 0900000 螺母垫圈支架水泵张紧轮装配总成隔套 NUT SUPPOT BRACKET CLOSING WHEEL SPACER BUSH 7 9 0 0900000 0900000 GBT7-0 09000000 0900000 轴顶杆深沟球轴承齿轮室垫片张紧轮 SHAFT TOP ROD BEARING GASKET TENSION PULLEY

9

QC95T5-- 0.- 正时齿轮室总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 0900000 GBT57-MX0 09000070 GBT57-M0X5 GBT97.-0 轴承盖六角头螺栓发电机支架螺栓垫圈 0 BEARING COVER GENERATOR BRACKET 0 9 0900000 000000 齿轮室 加机油口盖合件 GEAR CHAMBER COVER 0

QC95T5-- 0.- 飞轮壳总成 FLYWHEEL COVER ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 5 GBT70-M GBT97.- GBT9- GBT9-MX0 0900000 螺母垫圈垫圈双头螺柱飞轮壳 NUT.-AL STUD Flywheel Housing 7 GBT57-MX0 09000090 螺栓 飞轮壳垫片 FLYWHEEL HOUSING GASKET

QC95T5-- 0.- 高压油管总成 HIGH PRESSURE OIL PIPE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark.5 5 7 9 0900000 09000000 0900000 0900000 0900000 050000 GBT70-M GBT59-5 0500000 GBT5-M5X0 第一缸高压油管部件高压油管总成第二缸高压油管部件第三缸高压油管部件第四缸高压油管部件喷油泵端接头螺母螺母 M 轻型弹簧垫圈夹箍开槽圆柱头螺钉 ST CYLINDER HIGHT-PRESSURE OIL PIPE ASSEMBLY HIGH PRESSURE OIL PIPE ASSEMBLY ST CYLINDER HIGHT-PRESSURE OIL PIPE ASSEMBLY ST CYLINDER HIGHT-PRESSURE OIL PIPE ASSEMBLY ST CYLINDER HIGHT-PRESSURE OIL PIPE ASSEMBLY OIL INJECTION PUMP JOINT NUT NUT M HOOP SCREW

5

QC95T5-- 0.- 机油泵总成 OIL PUMP ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0900500000 0500000 机油泵总成 集滤器部件 OIL PUMP ASSEMBLY OIL STRAINER

7

QC95T5--5 0.5- 呼吸器总成 BREATH ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 5 5 09000000 GBT5.-.X.55 GBT57-MX0 GBT57-MX0 GBT9-M 呼吸器总成液压气动用 O 形橡胶密封圈螺栓螺栓弹簧垫圈 M O-SEAL RING SPRING 7 GBT97.-M 垫圈

9

QC95T5-- 0.- 机油管路总成 OIL CIRCUIT ASSEMBLY 标号 代号 数量 Quantity 备注 Remark GBT57-MX5 GBT57-MX0 GBT57-MX0 GBT9- GBT97.- 六角头螺栓螺栓螺栓垫圈 垫圈 0-_ 5 0950700000 095070000 机油管 机油管垫片 PIPE LUB.OIL OIL PIPE GASKET 0

QC95T5--7 0.7- 水泵风扇总成 -7 WATER PUMP AND FAN ASSEMBLY-7 标号 代号 数量 Quantity 备注 Remark 0 GBT57-MX5 GBT57-MX5 090090005 05070000 05070000 六角头螺栓螺栓节温器盖节温器盖垫片节温器 THERMOSTAT COVER THERMOSTAT COVER GASKET THERMOSTAT 5 5 7 0900000 0900000 0900000 09009000 GBT9- 水泵总成进水弯管垫片进水弯管节温器壳垫片垫圈 WATER PUMP ASSEMBLY WATER INLET BENDING PIPE GASKET HOSE THERMOSTAT HOUSING GASKET 5 GBT97.- 0500000 0900009 GBT5-AV7X5 GBT5-AV7X70 垫圈冷却风扇风扇垫块三角带三角带 COOLING FAN FAN GASKET TRIANGLE BELT TRIANGLE BELT 7 9 09000500 GBT57-MX5 GBT57-MX55 三角带轮 六角头螺栓 六角头螺栓 V-BELT PULLEY 5

QC95T5-- 0.- 喷油泵 OIL INJECTION PUMP 标号 代号 数量 Quantity 备注 Remark 0900005-XBQ5Y 090000-BHQT5Y07 喷油泵 喷油泵 OIL INJECTION PUMP OIL INJECTION PUMP

5

QC95T5--9 0.9- 发电机总成 ALTERNATOR ASSY 标号 代号 数量 Quantity 备注 Remark 5 GBT70-M0 GBT97.-0 090000 GBT57-M0X05 09000000 螺母 M0 垫圈 0 发电机总成螺栓发电机护罩合件 NUT M0 0 Generator assembly GENERATOR BONNET ASSEMBLY

7

QC95T5--0 0.- 正时齿轮传动系总成 TIMING GEAR ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 090000000 00050000 GBT57-MX55 0900000900 0900000700 凸轮轴止推板压板六角头螺栓凸轮轴正时齿轮曲轴正时齿轮 CAMSHAFT THRUST PLATE PRESSURE PLATE CAMSHAFT TIMING GEAR CRANKSHAFT TIMING GEAR 5 050000900 GBT9- GBT57-MX5 GBT97.- GBT9- 凸轮轴正时齿轮压板垫圈六角头螺栓垫圈垫圈 CAMSHAFT TIMING GEAR PRESSURE PLATE 9 5 7 9 9 GBT57-MX 090000000 0900000500 0900000 090000000 090000000 090000000 六角头螺栓正时惰齿轮轴正时惰齿轮衬套喷油泵正时齿轮连接盘喷油泵正时齿轮正时惰齿轮正时惰齿轮 TIMING IDLE GEAR SHAFT TIMING IDLE GEAR BUSH OIL INJECTION PUMP TIMING GEAR CONNECTING PLATE OIL INJECTION PUMP TIMING GEAR TIMING LAZY GEAR TIMING LAZY GEAR

9

QC95T5--0 0.0- 燃油供给总成 -0 FUEL SUPPLY SYSTEM ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0900007 09000000 09000000 喷油器回油管部件 输油泵出油管部件 滤清器出油管部件 OIL INJECTOR RETURN PIPE PARTS VITTA FILTER OIL OUTPUT PIPE PARTS 0

QC95T5-- 0.- 喷油器总成 FUEL INJECTOR ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 090050000 0900500 喷油器总成 油嘴偶件 INJEKTOR ASSEMBLY NOZZLE FITTING

QC95T5-- 0.- 机油滤清器总成 OIL FILTER ASSEMBLY 标号 代号 数量 Quantity 备注 Remark. 05000700 050000 JX00D GBT9- GBT97.- 机油滤清器垫片机油滤清器机油滤清器滤芯垫圈 垫圈 OIL FILTER GASKET OIL FILTER OIL FILTER ELEMENT 5 GBT57-MX5 GBT57-MX50 螺栓 六角头螺栓

5

QC95T5-- 0.- 燃油滤清器总成 - FUEL FILTER ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 050000 GBT9- GBT97.- GBT57-MX0 燃油滤清器总成垫圈 垫圈六角头螺栓 CX070TFUELFILTERASSEMBLYCX070T

7

QC95T5-- 0.- 起动电机总成 STARTING MOTOR ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 090000009 GBT70-M GBT9- GBT9-MX5 起动电机螺母垫圈双头螺柱 Motor Starter NUT.-AL STUD

9

QC95T5--0 0.- 气缸盖总成 CYLINDER HEAD ASSY 标号 代号 数量 Quantity 备注 Remark 0 0950000700 0500000 09000000 GBT7-M0XX0 GBT9.- 气门弹簧上座气门间隙调整螺母气门间隙调整螺钉开槽平端紧定螺钉挡圈 VALVE SPRING UPPER SEAT VALVE CLEARANCE ADJUSTING NUT VALVE CLEARANCE ADJUSTING SCREW SCREW RETAINER RING 5 7 09000000 0900000 0900000 09500000 090000500 垫片气门摇臂衬套气门摇臂摇臂座气门摇臂弹簧 VALVE ROCKER BUSH VALVE ROCKER BRACKET-ROCKER ARM SHAFT VALVE ROCKER SPRING 9 090000090 05000000 GBT57-MX0 GBT57-MX0 GBT57-MX0 吊耳气门锁夹螺栓螺栓六角头螺栓 BRACKET,LIFTING LOCK 7 0000000 09500000 095000700 09500000 095000500 气门油封总成排气门座进气门座气门导管排气门 VALVE OIL SEAL ASSEMBLY INSERT-VALVE SEAT(OUTLET) AIR INLET VALVE SEAT VALVE STEM GUIDE EXHAUST VALVE 5 0500000 GBT9-M0 09000000 095000000 09500000 碗形塞盖形螺母螺母气门摇臂轴支座螺栓摇臂轴 BOWL PLUG NUT NUT OF ROCKER ARM SEAT ROCKER SHAFT 0

QC95T5--0 0.- 气缸盖总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark 7 9 095000700 095000700 090000000 09500000 09000000 后摇臂轴后摇臂轴排气管垫片堵塞后端盖垫片 REAR ROCKER SHAFT REAR ROCKER SHAFT EXHAUST PIPE GASKET PLUG REAR END COVER GASKET 0 09500000 09000000 095000900 09500000 090000000 进气门后端盖堵塞气缸盖进气管垫片 AIR INLET VALVE REAR END COVER PLUG CYLINDER COVER AIR INLET PIPE GASKET 5 5 7 09500000 0900000500 090000000 GBT70-M GBT9- 前摇臂座气门内弹簧气门外弹簧螺母 M 垫圈 PRECEDING ROCKER ARM SEAT INNER VALVE SPRING OUTER VALVE SPING NUT M 9 0500000 喷油器压板螺栓 OIL INJECTOR PRESSURE PLATE

QC95T5--0 0.- 活塞 连杆总成 PISTONS & CONNECTING RODS 标号 代号 数量 Quantity 备注 Remark 5 095000000 095000000 GBT9.-9 095000000 095000000 活塞环总成活塞挡圈活塞销连杆总成 PISTON RING ASSEMBLY PISTON RETAINER RING PISTON PIN CONNECTING ROD ASSEMBLY 095000000 连杆轴瓦 CONNECTING ROD BEARING

5

QC95T5--05 0.5- 曲轴 飞轮总成 CRANKSHAFT FLYWHEEL ASSEMBLY 标号 代号 数量 Quantity 备注 Remark.. 090005000 GBT9.-B0X5 090005000 09000500 090005000 飞轮螺栓圆柱销飞轮齿圈部件飞轮飞轮齿圈 FLYWHEEL PIN FLYWHEEL RING GEAR ASSEMBLY FLYWHEEL GEAR RING OF FLYWHEEL 5 7 GBT7-0 0950050000 0950050000 GBT09-AX 0900050007 深沟球轴承曲轴前甩油盘平键曲轴皮带轮 BEARING CRANK SHAFT FRONT LUBRICATING DISC FLAT KEY GRANK SHAFT PULLEY 9 05000000 起动爪垫圈 STARTING CLAW

7

QC95T5--0 0.- 凸轮轴总成 CAMSHAFT ASSY 标号 代号 数量 Quantity 备注 Remark 090000000 090000000 GBT09-CX 09000000 气门推杆气门挺柱平键凸轮轴 VALVE PUSH ROD VALVE TAPPET FLAT KEY CAMSHAFT

9

QC95T5--07 0.7- 油底壳总成 OIL SUMP ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 09000700700 09000700900 GBT57-MX0 GBT57-MX0 GBT9-M 双头螺栓前支撑脚六角头螺栓六角头螺栓垫圈 STUD FRONT SUPPORT FOOT 5 7 0000 JBT9-77 GBT57-MX0 0900070000 GBT57-MX75 放油螺塞垫圈 0 六角头螺栓双头螺柱六角头螺栓 OIL DISCHARGING SCREW PLUG 0.-AL STUD 9 9 0 0000000 09000700500 09000700 GBT9- GBT97.- 机油尺导管焊合件右护板油标尺部件垫圈 垫圈 OIL DIPSTICK PIPE RIGHT GUARD PLATE OIL DIPSTICK ASSEMBLY 5 5 5 7 9 GBT70-M GBT9.-BX 090007000 00000700 0900070000 螺母 M 圆柱销油底壳垫片油底壳左护板 NUT M PIN OIL SUMP GASKET OIL SUMP LEFT GUARD PLATE 50

5

QC95T5--0 0.- 排气管总成 - EXHAUST PIPE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 5 090000000 09000000 GBT97.- GBT9- GBT57-MX5 排气管垫片排气管垫圈垫圈 螺栓 EXHAUST PIPE GASKET EXHAUST PIPE 7 9 GBT57-M0X5 09000000 GBT9-0 GBT70-M0 螺栓排气总管衬垫垫圈 0 螺母 M0 GASKET 0 NUT M0 5

5

QC95T5--09 0.9- 进气管总成 -9 INTAKE PIPE ASSEMBLY-9 标号 代号 数量 Quantity 备注 Remark 0 090000000 0050000 09000900 GBT97.- GBT9- 进气管垫片火焰预热塞进气管垫圈垫圈 AIR INLET PIPE GASKET FLAME WARM-UP PLUG AIR INLET PIPE 5 7 9 GBT57-MX0 050090000 090009000 GBT70. 0050000 六角头螺栓进气接管垫片进气接管螺栓 M0 5-AL 管路附件 AIR INLET CONNECTING PIPE AIR INLET CONNECTING PIPE M0 Á5-AL PIPELINE ACCESSORIES 0-0_ 9 0050000 管路附件 PIPELINE ACCESSORIES 5

55

TB00. - 空气滤清系总成 -AIR CLEANER ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 0 TB00..-05 TB00..-05 Q7 TB00.-0 TB00.. 空气滤清器滤芯空气滤清器滤芯环箍空滤器进气软管空气滤清器总成 AIR FILTER CORE AIR FILTER CORE Clip AIR INLET HOSE OF AIR FILTER AIR FILTER ASSEMBLY 0-_ 0-_ 0-_ 0-_ 0-_. 5 7 TD900.A-0 GBT57-MX5-AL GBT9--A0P TB00.. GBT97.--A0P 空气滤清器保养指示器螺栓垫圈空滤器安装支架焊合平垫圈 AIR FILTER MAINTENANCE INDICATOR AIR FILTER ASSEMBLY BRACKET WELDMENT 0-0_ 0-_ 0-_ 0-_ 0-_ 9 GBT70-M-AL GBT57-MX-AL 螺母 螺栓 NUT 0-_ 0-_ 5

57

TB500.D - 冷却系总成 -COOLING SYSTEM ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 TB500.Y.5 GBT97.--A0P GBT57-MX0-AL FT50.. GBT57-M0X0-AL 空滤器安装支架平垫圈螺栓橡胶垫块螺栓 AIR FILTER ASSEMBLY BRACKET RUBBER PAD BLOCK 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT9-0-A0P GBT97.-0-A0P TB500.Y. FT50.. GBT7-M0-AL 标准型弹簧垫圈平垫圈水箱垫板焊合垫片 型六角开槽螺母 RADIATOR BACKING BOARD WELDMENT NUT (PAGE) 0-_ 0-_ 0-_ 0-_ 0-_ 9 5 GBT9-.5X-A0P TB550.. TB500.C. QCT9-Q757 TB500.-0 开口销拉杆合件散热器总成 B 型蜗杆传动式软管环箍水箱进水软管 PIN PULL ROD UNIT RADIATER ASSEMBLY B-TYPE WORM TRANSMISSION HOSE CLAMP WATER TANK INLET HOSE 0-_ 0-_ 0-_ 0-_ 0-0_ 5 5 7 TB500.D-0 TB500.-0 FT50..0 GBT9--A0P GBT9--A0P 水箱进水软管水箱进水软管水箱出水软管大垫圈垫圈 WATER TANK INLET HOSE WATER TANK INLET HOSE WATER TANK OUTLET HOSE 0-_ 0-0_ 0-_ 0-_ 0-_ 9 GBT70-M-AL 螺母 NUT 0-_ 5

59

TB00.0F 0.- 手油门总成 0.-HAND THROTTLE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 TA700.0-0 FT50.0. GBT-MX0-AL GBT-M 0-AL FT00.0.05 手油门总成紧固螺钉十字槽盘头螺钉十字槽盘头螺钉手油门拉线支架 HANDLE THROTTLE ASSEMBLY LOCKING SCREW SCREW SCREW PULL WIRE BRACKET OF HAND THROTTLE 0-_ 0-_ 0-_ 0-_ 00-0_ FT00.0.05 FT00.0.05 GBT9--A0P GBT9--A0P GBT57-MX-AL 手油门拉线支架手油门拉线支架垫圈弹簧垫圈六角头螺栓 PULL WIRE BRACKET OF HAND THROTTLE PULL WIRE BRACKET OF HAND THROTTLE SPRING 00-0_ 00-0_ 0-_ 0-_ 0-_ 5 7 FT700.0. GBT570-M0X5-AL GBT9-0-A0P GBT-MX0-AL GBT70-M-AL 手油门盖六角头螺栓垫圈开槽沉头螺钉螺母 HAND THROTTLE COVER SCREW NUT 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT97.--A0P 平垫圈 0-_ 0

TB00.0B 0.- 脚油门总成 0.-FOOT THRORRLE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT79.-5X0 GBT57-MX0-.-AL FT00.0.0 FT00.0.0 FT50.0.0 弹性圆柱销六角头螺栓脚油门摇臂焊合脚油门拉线支架焊合脚踏板 PIN FOOT THROTTLE ROCKER ARM WELDMENT FOOT THROTTLE WIRE BRACKET WELDMENT FOOT PEDAL 00-0_ 0-_ 0-_ 00-0_ 0-_ 5 7 FT50.0.07 FT00.0.0 GBT57-M5X-AL FT50.0.0 FT50.0.0 橡胶塞脚踏板摇臂焊合六角头螺栓扭簧油门支架 RUBBER RING FOOT PEDAL ROCKER ARM WELDMENT TORSION SPRING THROTTLE PEDESTAL 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT70-M-AL FT50.0. 螺母 手油门摇臂 NUT HAND THROTTLE ROCKER 0-_ 0-_

TB00.0B 0.- 拉线总成 0.-PULL WIRE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark FT50.0.0 GBT9-X-A0P GBT9-X-A0P GBT-B5X0-A0P FT00.0.0 脚油门拉线总成开口销开口销销轴熄火拉线总成 FOOT THROTTLE WIRE ASSEMBLY PIN PIN PIN EXTINGUISH WIRE ASSEMBLY 0-_ 00-0_ 009-0_ 00-0_ 0-_

5

TB550.. - 离合器总成 -CLUTCH ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 0 TB550. FT00.B.0 FT00.B.0 FT00.B.09 GBT9-.X-A0P.- 离合器总成副离合器拉杆顶杆销轴开口销.-CLUTCH ASSEMBLY AUXILIARY CLUTCH PULL ROD TOP ROD PIN PIN 0 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT-0-A0P FT00.B.07 FT00.B. FT00.B.0 FT00.B.0 小垫圈主离合器分离杠杆长销主分离杠杆弹簧副离合器分离杠杆 MAIN CLUTCH RELEASE LEVER LONG PIN MAIN RELEASE LEVER SPRING AUXILIARY CLUTCH RELEASE LEVER 0-_ 0-_ 0-_ 0-_ 0-_ 9 9 0 5 7 9 GBT7-MX-AL FT00.B.05 FT00.B.05 FT00.B.05 FT00.B.0 GBT57-M0X0-AL GBT9-0 FT00.B.0 TB550.-0 FT00.B. GBT7-M0X-AL FT00.B. FT00.B.0 FT00.B. 型六角螺母球头螺母球头螺母副离合器磨擦片总成副分离杠杆弹簧螺栓垫圈 0 副离合器压盘碟形弹簧主离合器调整螺钉螺母主离合器压盘主离合器磨擦片总成离合器盖 NUT BALL NUT BALL NUT AUXILIARY CLUTCH FRICTION PLATE ASSEMBLY AUXILIARY RELEASE LEVER SPRING 0 AUXILIARY CLUTCH PRESSURE PLATE DISC SPRING MAIN CLUTCH ADJUSTING SCREW NUT MAIN CLUTCH PRESSURE PLATE MAIN CLUTCH FRICTION PLATE ASSEMBLY CLUTCH COVER 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_

7

TB550..- 离合器总成.-CLUTCH ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 FT00.B.0 FT00.B.0 FT00.B.09 GBT9 GBT 副离合器拉杆顶杆销轴开口销. 5 小垫圈 AUXILIARY CLUTCH PULL ROD TOP ROD PIN COTTER PIN. Á5 SMALL 0 0-0_ 0-0_ 0-0_ 0-0_ 0-0_ 5 7 FT00.B.07 FT00.B. FT00.B.0 FT00.B.0 GBT7 主离合器分离杠杆长销主分离杠杆弹簧副离合器分离杠杆 型六角螺母 M0X MAIN CLUTCH RELEASE LEVER LONG PIN MAIN RELEASE LEVER SPRING AUXILIARY CLUTCH RELEASE LEVER -TYPE HEX NUT M0X 0-0_ 0-0_ 0-0_ 0-0_ 0-_ 9 9 0 5 7 9 FT00.B.05 FT00.B.05 FT500A.B.05 FT00.B.05 FT00.B.0 GBT57 GBT9 FT00.B.0 TB550.-0 FT00.B. GBT7 FT00.B. FT500A.B.0 FT00.B.0 FT00.B. 球头螺母球头螺母副离合器磨擦片总成副离合器磨擦片总成副分离杠杆弹簧六角头螺栓标准型弹簧垫圈副离合器压盘碟形弹簧主离合器调整螺钉 型六角螺母 M0X 主离合器压盘主离合器磨擦片总成主离合器磨擦片总成离合器盖 BALL NUT BALL NUT AUXILIARY CLUTCH FRICTION PLATE ASSEMBLY AUXILIARY CLUTCH FRICTION PLATE ASSEMBLY AUXILIARY RELEASE LEVER SPRING AUXILIARY CLUTCH PRESSURE PLATE DISC SPRING MAIN CLUTCH ADJUSTING SCREW -TYPE HEX NUT M0X MAIN CLUTCH PRESSURE PLATE MAIN CLUTCH FRICTION PLATE ASSEMBLY 0-0_ 0-0_ 00-0_ 0-0_ 0-0_ 0-0_ 0-0_ 0-0_ 0-0_ 0-0_ 0-0_ 00-0_ 0-0_

9

TB50..- 离合器操纵机构总成.-CLUTCH CONTROL MECHANISM ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT7-0-RS GBT9-0-AOP GBT-B0X FT00..0 GBT97.-0-A0P 轴承标准型弹簧垫圈销轴拉杆后叉平垫圈 BEARING PIN PULL ROD REAR FORK 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT9-.X-A0P GBT70-M0-LH-AL FT00..0 GBT70-M0-AL FT00..0 开口销螺母拉杆螺母拉杆前叉 PIN NUT PULL ROD NUT PULL ROD FRONT FORK 0-_ 0-_ 0-_ 0-_ 9 0 GBT57-M0X0-.-AL TA00.-0 FT00..0 TB50.-0 GBT9--A0P 螺栓推力轴承 99 7 离合器分离叉轴合件离合器踏板焊合弹簧垫圈 THRUST BEARING CLUTCH RELEASE FORK SHAFT UNIT CLUTCH PEDAL WELDMENT SPRING 7 0-_ 0-_ 0-_ 0-_ 0-_ 5 GBT57-Mx-AL FT00.B.0 FT00..0 FT00..0 FT00.. 螺栓分离轴承座推力轴承座回位弹簧分离拨叉止动螺钉 RELEASE BEARING SEAT THRUST BEARING SEAT RETURN SPRING RELEASE SHIFT FORK THRUST SCREW 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 TA00.B-0 TB50.. FT00..0 低碳钢丝 离合器踏板体合件 踏板回位弹簧 LOW CARBON STEEL WIRE CLUTCH PEDAL BODY UNIT PEDAL RETURN SPRING 0-_ 0-_ 0-_ 70

7

TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark FT0.F.0 GBT9--A0P GBT9--A0P GBT57-MX5-0.9-AL 前驱动桥分总成弹簧垫圈弹簧垫圈螺栓 FRONT DRIVING AXLE SUB-ASSEMBLY SPRING SPRING 0-_ 0-_ 0-_ 0-_ 7

7

TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 FT0.F.0 GBT57-M 0-.-AL JBT790.-M0X QYXF70-Z/ GBT0.-A0 前驱动桥分总成六角头螺栓直通式压注油杯螺塞油标 FRONT DRIVING AXLE SUB-ASSEMBLY STRAIGHT PRESSURE FILLING OIL CUP SCREW PLUG DIPSTICK 0-_ 0-_ 0-_ 5 7 FT0.F. FT0.F. GBT7-09 FT0.F. FT0.F.7 半轴壳体齿轮深沟球轴承花键轴套管 HALF SHAFT HOUSING GEAR BEARING SPLINE SHAFT SLEEVE 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT0.F. FT0.F.0 GBT9- GBT7-MX.5-0-AL FT0.F.05 调整垫片调整垫片垫圈 型六角螺母垫圈 ADJUSTING ADJUSTING HEXAGON NUT, TYPE- 0-_ 0-_ 0-_ 00-0_ 0-_. 5 FT0.F.7 FT0.F.5 FT0.F 5*. GBT57-MX5 前驱动轴滚花螺栓浮动油封 O 形圈六角头螺栓 FRONT DRIVING SHAFT FLOATING OIL SEAL O-RING 5 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 GBT9- FT0.F.07 FT0.F.90 GBT5.-X5.G FT0.F. 垫圈 端部大盖调整垫液压气动用 O 形橡胶密封圈连接盖 BIG END COVER ADJUSTING GASKET O-SEAL RING CONNECTING COVER 0-_ 0-_ 0-_ 0-_ 0-_ 7

75

TB50.-..- 前驱动桥总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 0 GBT7-0 FT0.F. FT0.F.0 GBT7-0 FT0.F. 轴承挡圈端部大齿轮深沟球轴承调整垫 BEARING RETAINER RING BIG END GEAR BEARING ADJUSTING GASKET 0-_ 0-_ 0-_ 0-_ 5 7 FT0.F.0 FT0.F. GBT0-507 FT0.F.05 FT0.F.05 端部花键轴衬套轴承螺塞螺塞 END SPLINE SHAFT SLEEVE BEARING SCREW PLUG SCREW PLUG 0-_ 0-_ 9 0 FT0.F.0 GBT977.-FB0X05X GBT70-M GBT57-MX50-0.9-AL FT0.F.09 垫圈内包骨架旋转轴唇形密封螺母六角头螺栓左末端壳体 O RING NUT LEFT END HOUSING 0-_ 0-_ 0-_ 0-_ 5 7 FT0.F. GBT7-0 GBT9.-90 FT0.F.0 GBT9.-0 端部小齿轮深沟球轴承挡圈 90 密封盖孔用弹性挡圈 END PINION BEARING RETAINER RING SEAL CAP SNAP RING 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 FT0.F.5 GBT7-0 GBT9.-00 FT0.F. FT0.F. 油封衬套深沟球轴承孔用弹性挡圈平垫齿轮 OIL SEAL BUSH BEARING SNAP RING GEAR 0-_ 0-_ 0-_ 0-_ 0-_ 7

77

TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 0 FT0.F.0 GBT5.-0X.5G FT0.F. FT0.F. FT0.F. 前驱动桥分总成 O 型密封圈隔套隔套调整套 FRONT DRIVING AXLE SUB-ASSEMBLY O RING SPACER BUSH SPACER BUSH ADJUSTING SLEEVE 0-_ 0-_ 0-_ 0-_ 0-_ 5 GBT9.-7 GBT977.-F50X7XD FT0.F. GBT5.-.5X.55G FT0.F.0 挡圈内包骨架旋转轴唇形密封油封座液压气动用 O 形橡胶密封圈铜垫 RETAINER RING O RING OIL SEAL CAGE O-SEAL RING COPPER 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 0 5 7 9 GBT0-M0X.5 GBT5-0 FT0.F. FT0.F.9 GBT7- FT0.F.7 GBT9-BX0 GBT9-BX0 FT0.F.9 FT0.F. FT0.F.0 FT0.F. FT0.F. FT0.F. FT0.F. 小圆螺母止退垫圈中央传动大螺伞齿轮定位盘深沟球轴承差速器右壳圆柱销圆柱销隔圈半轴齿轮垫圈行星齿轮销轴止动销差速器左壳 NUT LOCK CENTRAL TRANSMISSION BIG SPIRAL BEVEL GEAR LOCATING PLATE BEARING DIFFERENTIAL RIGHT HOUSING PIN PIN HALF SHAFT GEAR PLANETARY GEAR PIN THRUST PIN 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 7

79

TB50.-..- 前驱动桥总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 0 5 FT0.F.9 GBT9-0 GBT70-M0X70 FT0.F.0 FT0.F.05 主减速箱壳体垫圈 0 内六角圆柱头螺钉垫圈螺塞 MAIN REDUCER BOX HOUSING 0 SCREW SCREW PLUG 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 FT0.F.05 GBT9-BX0 GBT5.-90X.5G FT0.F. GBT97-07 螺塞圆柱销液压气动用 O 形橡胶密封圈主动螺伞齿轮轴圆锥滚子轴承 SCREW PLUG PIN O-SEAL RING DRIVING SPIRAL BEVEL GEAR SHAFT BEARING 0-_ 0-_ 0-_ 0-_ 0-_ 0

TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 FT0.F.0 GBT57-MX0-0.9-AL JBT790.-M0X GBT70-M 5 GBT0.-A0 前驱动桥分总成六角头螺栓直通式压注油杯螺钉 M 5 油标 FRONT DRIVING AXLE SUB-ASSEMBLY STRAIGHT PRESSURE FILLING OIL CUP SCREW DIPSTICK 0-_ 0-_ 0-_ 5 7 FT0.F. FT0.F. GBT7-09 FT0.F.5 FT0.F.7 半轴壳体齿轮深沟球轴承花键轴套管 HALF SHAFT HOUSING GEAR BEARING SPLINE SHAFT SLEEVE 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT0.F. FT0.F.0 GBT9- FT0.F.0 FT0.F 调整垫片调整垫片垫圈端部花键轴浮动油封 ADJUSTING ADJUSTING END SPLINE SHAFT FLOATING OIL SEAL 0-_ 0-_ 0-_ 0-_ 0-_ 5 FT0.F. GBT0-07 FT0.F.05 FT0.F.05 FT0.F.0 衬套推力球轴承螺塞螺塞垫圈 SLEEVE HANDSPIKE BALL BEARING SCREW PLUG SCREW PLUG 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 FT0.F. GBT70-M QJ55..B FT0.F. FT0.F. 右末端壳体螺母调整垫片端部小齿轮连接盖 RIGHT END HOUSING NUT ADJUSTING END PINION CONNECTING COVER 999 0-_ 0-_ 0-_ 0-_ 0-_

TB50.-..- 前驱动桥总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 0 GBT7-0 FT0.F. GBT9.-90 FT0.F.0 GBT9.-0 深沟球轴承调整垫挡圈 90 密封盖孔用弹性挡圈 BEARING ADJUSTING GASKET RETAINER RING SEAL CAP SNAP RING 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 GBT7-0 FT0.F.0 FT0.F. GBT7-0 GBT5.-X5.G 深沟球轴承端部大齿轮挡圈轴承液压气动用 O 形橡胶密封圈 BEARING BIG END GEAR RETAINER RING BEARING O-SEAL RING 0-_ 0-_ 0-_ 0-_ 0-_ 0 GBT977.-FB0X05X FT0.F.90 FT0.F.07 GBT9- GBT57-MX5 内包骨架旋转轴唇形密封调整垫端部大盖垫圈 六角头螺栓 O RING ADJUSTING GASKET BIG END COVER 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 5 FT0.F.7 FT0.F.5 FT0.F.05 GBT7-MX.5 FT0.F.5 前驱动轴滚花螺栓垫圈螺母 X.5 油封衬套 FRONT DRIVING SHAFT NUT OIL SEAL BUSH 0-_ 0-_ 0-07_ 0-_ 7 9 GBT7-0 GBT9.-00 FT0.F. FT0.F. 深沟球轴承孔用弹性挡圈平垫齿轮 BEARING SNAP RING GEAR 0-_ 0-_ 0-_ 0-_

5

TB50.-5..5- 前驱动桥总成 -5 FRONT DRIVING AXLE ASSEMBLY-5 标号 代号 数量 Quantity 备注 Remark..... FT0.F.0 FT0.F.0 FT0.F.07 FT0.F.0 FT0.F.0 左油缸球头总成左油缸球头总成右油缸球头总成右转向球头总成左转向球头总成 LEFT CYLINDER JOINT ASSEMBLY LEFT CYLINDER JOINT ASSEMBLY RIGHT OIL CYLINDER JOINT ASSEMBLY STEERING BALL HEAD ASSY RIGHT STEERING BALL HEAD ASSY LEFT 0-_ 0-_ 0-_ 0-_ 0-_ 0 FT0.F.0 FT0.F.7 FT0.F. GBT9 GBT7-M0X.5 防尘帽隔套六角开槽螺母开口销. 5 六角薄螺母 DUSTPROOF CAP SPACER BUSH HEXAGON SLOTTED NUT COTTER PIN. Á5 NUT 0-_ 0-_ 0-_ 0-_ 5 7 FT0.F.07 Q50MZ00-50 FT0.F.09a FT0.F. FT0.F.0A 防尘皮套管箍液压缸卡簧防尘皮嚢 DUSTPROOF LEATHER SLEEVE PIPE HOOP HYDRAULIC CYLINDER CIRCLIP DUSTPROOF POCKET 0-_ 0-_ 0-_ 0-_ 00-07_ 9 0 0 FT0.F.7A JBT790.-MX JBT790.-MX JBT790.-MX JBT790.-MX 左球头销座油杯油杯油杯油杯 LEFT BALL PIN SEAT OIL CUP OIL CUP OIL CUP OIL CUP 0-_ 0-_ 0-_ 0-_ 0-_ 5 0..5 FT0.F.77A 00..5 00..5 FT0.F.7 球头销座球头销球头销盖弹簧压盖 BALL HEAD PIN SEAT BALL PIN BALL PIN COVER SPRING PRESSURE COVER 0-_ 00-07_ 0-_ 0-_ 0-_

7

TB50.-5..5- 前驱动桥总成 -5( 续 ) 标号 代号 数量 Quantity 备注 Remark 7 9 GBT5.-.5X.G GBT9.-7 GBT7-M0X.5-LH FT0.F.75 FT0.F.5a O 型圈孔用弹性挡圈 型六角螺母拉杆固定销 O-RING SNAP RING NUT PULL ROD FIXING PIN 0-_ 0-_ 0-_ 0-_ 0 5 GBT7-M0X.5 FT0.F.7A GBT9.-5 GBT9-GE0ES FT0.F.5 型六角螺母右球头销座挡圈向心关节轴承左护板 NUT RIGHT BALL PIN SEAT RETAINER RING BEARING LEFT GUARD PLATE 0-_ 0-_ 0-_ 0-_. 7 9 9. FT0.F. GBT57-MX GBT9- FT0.F.95 FT0.F.9 右护板螺栓垫圈 左活塞杆耳环右活塞杆耳环 RIGHT GUARD PLATE EAR RING OF LEFT PISTON ROD RIGHT PISTON ROD EAR RING 0-_ 0-_ 0-_

9

TB50.-..- 前驱动桥总成 - FRONT DRIVING AXLE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 FT0.F.0 GBT57-MX0-.-AL FT0.F.7 GBT5.-5X.55G GBT57-MX0-Zn.D 前驱动桥分总成六角头螺栓支撑轴液压气动用 O 形橡胶密封圈螺栓 FRONT DRIVING AXLE SUB-ASSEMBLY SHAFT O-SEAL RING 0-_ 0-_ 0-_ 0-_ 5 7 GBT9- GBT790.-MX GBT57-MX0-0.9 GBT9- GBT70-M 垫圈 油杯六角头螺栓全螺纹垫圈螺母 OIL CUP NUT 0-_ 0-_ 0-_ 0-_ 9 0 GBT900-AMX0-.-Zn.D FT0.F.5 GBT70-M GBT5.-5X.55G FT0.F.55 螺柱滑动轴承螺母液压气动用 O 形橡胶密封圈后支撑轴座 STUD SLIDING BEARING NUT O-SEAL RING REAR SUPPORTING SHAFT SEAT 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 FT0.F.05 FT0.F.9 FT0.F.50 FT0.F. GBT790.-MX 密封垫前支撑轴座垫片滑动轴承油杯 SEAL GASKET FRONT SUPPORT SHAFT SEAT SLIDING BEARING OIL CUP 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT5.-7.5X.55G FT0.F.0 液压气动用 O 形橡胶密封圈 连接销 O-SEAL RING CONNECTING PIN 0-_ 0-_ 90

9

TB55..- 前托架总成.-FRONT BRACKET ASSEMBLY 标号 代号 数量 Quantity 备注 Remark GBT57-MX0-0.9-AL GBT9--A0P TB55.-0 六角头螺栓 弹簧垫圈 前托架 SPRING FRONT BRACKET 0-_ 0-_ 0-_ 9

9

FT0.F.00 - 前驱动轮总成 -FRONT DRIVING WHEEL ASSEMBLY 标号 代号 数量 Quantity 备注 Remark GBT979-.-0-PR-PR GBT979-.-0-R FT0.F.0 拖拉机驱动轮水田专用斜交结构外胎 拖拉机驱动轮内胎 轮辋焊合 DRIVING WHEEL OUTER TUBE DRIVING WHEEL INNER TUBE WHEEL RIM WELD 0-0_ 0-_ 9

95

FT00.F.00 - 后驱动轮总成 -REAR DRIVE WHEEL ASSEMBLY 标号 代号 数量 Quantity 备注 Remark. GBT979-.--PR-R GBT979-.--R GBT979-.--R FT00.F.0 GBT7-MX.5-AL 拖拉机驱动轮普通断面斜交结构外胎拖拉机驱动轮内胎拖拉机驱动轮内胎轮辋总成 型六角螺母 DRIVING WHEEL OUTER TUBE DRIVING WHEEL INNER TUBE DRIVING WHEEL INNER TUBE RIM ASSEMBLY NUT 0-_ 0-_ 0-_ 0-_ 0-_....5 FT00..0 FT00.F.0 FT00..0b FT00..0 垫圈轮辋焊合轮辐轮辋螺栓 WHEEL RIM WELD SPOKE RIM 0-_ 0-_ 0-_ 0-_ 9

97

TB00.7A 7.- 变速箱壳体总成 7.-GEARBOX HOUSING ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 TB00.7E-0 FT00.7.0b FT00.7.0b TB00.7E-0 GBT70-M-AL 变速箱壳体变速箱壳体变速箱壳体下堵盖螺母 GEAR BOX GEAR BOX GEAR BOX LOWER PLUG COVER NUT 007-_ 00-0_ 00-0_ 00-0_ 0-_ 5 GBT7-MX.5-AL GBT57-M 0-AL GBT9.-mX-A0P GBT57-M 70-AL GBT57-MX70-AL 型六角螺母螺栓圆柱销六角头螺栓六角头螺栓 NUT PIN 0 00-0_ 00-0_ 0-_ 00-0_ 00-0_ 5 5 5 5 GBT57-MX5-AL GBT57-M0X5-AL GBT57-MX0-AL GBT57-MX5-AL GBT7-M.5-AL 螺栓螺栓螺栓螺栓螺母 NUT 0 0-_ 00-0_ 00-0_ 0-_ 00-0_ 5 GBT9--A0P GBT9-0-A0P GBT99-AM-MX.5X5-.-AL FT00.7.5 JBT790.-M0X 弹簧垫圈标准型弹簧垫圈双头螺柱踏板轴衬套直通式压注油杯 SPRING.-AL STUD PEDAL SHAFT BUSH STRAIGHT PRESSURE FILLING OIL CUP 0 0-_ 00-0_ 0-_ 0-_ 0-_ 7 9 9 FT00.7.59 GBT9-.X0-A0P GBT9.-mX0-A0P GBT9.-mX0-A0P 分离叉轴衬套开口销圆柱销圆柱销 RELEASE FORK SHAFT BUSH PIN PIN PIN 0-_ 0-_ 0-_ 0-_ 9

99

TB50.7B- 7..- 主变速总成 - MAIN TRANSMISSION ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 FT00.7B.0 GBT9.-0 TB550.7- FT00.7B. FT00.7B.a 副离合器轴挡圈 0 Ⅰ 档齿轮隔套 Ⅰ 档主动齿轮 Ⅰ 档主动齿轮 AUXILIARY CLUTCH SHAFT 0 I GEAR SPACER I DRIVING GEAR I DRIVING GEAR 0-_ 0-_ 00-0_ 00-0_ 00-0_ FT00.7B.7a FT00.7B.7 TB550.7-9 FT00.7. FT00.7.0 Ⅰ-Ⅱ 档齿轮隔套 Ⅰ-Ⅱ 档齿轮隔套 Ⅰ-Ⅱ 档齿轮隔套 Ⅱ 档主动齿轮 Ⅲ 档齿轮衬套 I-II GEAR SPACER I-II GEAR SPACER I-II GEAR SPACER Ⅱ DRIVING GEAR III GEAR BUSH 007-0_ 00-0_ 00-0_ 0-_ 0-_ 5 7 9 FT00.7.a FT00.7. FT00.7.a GBT7-007 GBT9.- Ⅲ 档主动齿轮 Ⅲ-Ⅳ 档啮合齿座 Ⅲ-Ⅳ 档啮合套轴承 007 孔用弹性挡圈 Ⅲ DRIVING GEAR Ⅲ-Ⅳ ENGAGING GEAR SEAT Ⅲ-Ⅳ SHIFT COLLAR BEARING SNAP RING 0-_ 0-_ 0-_ 0-_ 0-_ 0 GBT57-MX5-AL FT00.7. FT00.7E.7 FT00.7E.7 GBT95.- 螺栓连接套动力输出连接轴动力输出连接轴轴用钢丝挡圈 CONNECTING SLEEVE PTO CONNECTING SHAFT PTO CONNECTING SHAFT SNAP RING 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT9- FT00.7B. FT00.7B.5 GBT977.-FB0XXD GBT7-0 垫圈 Ⅰ 轴轴承盖 Ⅰ 轴轴承盖纸垫内包骨架旋转轴唇形密封深沟球轴承 SHAFT I BEARING COVER SHAFT I BEARING COVER PAPER GASKET O RING BEARING 0-_ 0-_ 0-_ 0-_ 0-_ 00

0

TB50.7B- 7..- 主变速总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark.. FT00.7B.0 FT00.7B.0a FT00.7B.0a FT00.7B.0 FT00.7B.0a Ⅰ 轴合件 Ⅰ 轴合件 Ⅰ 轴合件 Ⅰ 轴 Ⅰ 轴 SHAFT I UNIT SHAFT I UNIT SHAFT I UNIT SHAFT I SHAFT I 00-0_ 00-0_ 00-0_ 00-0_ 00-0_. 9 FT00.7.70 GBT5.-.X.0G 衬套 液压气动用 O 形橡胶密封圈 SLEEVE O-SEAL RING 0-_ 0-_ 0

0

TB50.7B- 7..- 主变速总成 - MAIN TRANSMISSION ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 GBT57-MX5-AL FT00.7. FT00.7.7a FT00.7.7 FT00.7.5a 螺栓 Ⅰ-Ⅱ 档齿轮衬套 Ⅰ 档从动齿轮 Ⅰ 档从动齿轮 Ⅰ-Ⅱ 档啮合套 I-II GEAR BUSH I DRIVEN GEAR I DRIVEN GEAR I-II SHIFT COLLAR 0-_ 0-_ 0-0_ 00-0_ 0-0_ 5 FT00.7.5 FT00.7. FT00.7. FT00.7.a FT00.7. Ⅰ-Ⅱ 档啮合套 Ⅰ-Ⅱ 档啮合齿座 Ⅱ 档从动齿轮 Ⅱ 档从动齿轮 Ⅲ 档从动齿轮 I-II SHIFT COLLAR I-II ENGAGING TOOTH SEAT Ⅱ DRIVEN GEAR Ⅱ DRIVEN GEAR Ⅲ DRIVEN GEAR 00-0_ 0-_ 00-0_ 0-0_ 0-_ 7 9 FT00.7.0 FT00.7.0a GBT7-0 FT00.7.09a GBT9- Ⅲ-Ⅳ 档齿轮隔套 Ⅳ 档从动齿轮深沟球轴承 Ⅱ 轴垫圈 III-IV GEAR SPACER Ⅳ DRIVEN GEAR BEARING SHAFT Ⅱ 0-_ 0-_ 0-_ 0-_ 0-_ 0 5 JBT79-K0XX0 FT00.7.0 FT00.7.9 GBT-MX.5 GBT5- 向心滚针和保持架组件 Ⅱ 轴轴承盖 Ⅱ 轴轴承盖纸垫圆螺母圆螺母用止动垫圈 NEEDLE AND CARRIER UNIT SHAFT Ⅱ BEARING COVER SHAFT Ⅱ BEARING COVER PAPER GASKET ROUND NUT THRUST RING 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 GBT05-7-7. GBT7-0N FT00.7. 止动环 深沟球轴承 Ⅱ 轴轴端挡圈 THRUST RING BEARING SHAFT Ⅱ END RETAINER RING 00-0_ 0-_ 0-_ 0

05

TB50.7C- 7.- 变速箱操纵机构总成 7.-GEARBOX CONTROL MECHANISM ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT9-0 FT00.7.5 FT00.7. FT00.7.5 FT50.7.55 垫圈 0 副变速拨头倒档拨叉互锁销倒档拨叉轴 0 AUXILIARY GEARSHIFT DIAL HEAD REVERSE FORK MUTUAL PIN REVERSE FORK SHAFT 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 FT00.7.5 FT00.7.7 FT00.7.50 FT00.7.5 FT00.7.9 倒档拨头 Ⅲ-Ⅳ 档拨叉 Ⅲ-Ⅳ 档拨叉轴 Ⅰ-Ⅱ 档拨头 Ⅰ-Ⅱ 档拨叉轴 REVERSE DIAL HEAD Ⅲ-Ⅳ FORK Ⅲ-Ⅳ FORK SHAFT I-II GEAR FORK HEAD I-II GEAR FORK SHAFT 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT00.7. GBT57-M0X0-AL TB50.5A-0 Q7 GBT0--G00-B Ⅰ-Ⅱ 档拨叉螺栓密封盖塞片钢球 I-II GEAR FORK SEAL CAP PLUG PIECE BALL 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 FT00.7.5 FT00.7.5 GBT79.-X GBT79.-5X FT50.7.5 拨叉轴定位弹簧副变速拨叉弹性圆柱销弹性圆柱销副变速拨叉轴 FORK SHAFT LOCATING SPRING AUXILIARY GEARSHIFT FORK PIN PIN AUXILIARY GEARSHIFT FORK SHAFT 7 7 0-_ 0-_ 0-_ 0-_ 0-_ 0

07

TB50.7C- 7.. 变速箱操纵机构总成 - GEARBOX CONTROL MECHANISM ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 5 5 7 9 0 5 7 TB50.7C. FT00.7J.0 TF00.7-0 FT00.7.0 FT00.7.05 TB50.7B.. FT00.7.a FT00.7.5 FT00.7.5 FT00.7. FT00.7J. GBT5- GBT57-MX-AL GBT7.-M0-AL FT00.7. TB50.7B.-0 GBT79.-X GBT79.-X TB50.7B-0 TB50.7B.. TB50.7B.. FT00.7.a GBT9.-0 FT00A.7.05 GBT57-MX0-AL 变速箱盖总成副变速操纵手柄总成低碳钢丝变速杆支座主变速操纵手柄总成主变速杆焊合变速箱上盖变速杆弹簧变速杆弹簧变速杆弹簧挡圈副变速导板单耳制动垫圈螺栓螺母主变速导板下操纵杆弹性圆柱销弹性圆柱销变速杆防尘罩副变速杆焊合副变速杆焊合变速杆防尘罩挡圈尼龙座六角头螺栓 GEAR BOX COVER ASSEMBLY AUXILIARY GEARSHIFT CONTROL HANDLE ASSEMBLY LOW CARBON STEEL WIRE GEARLEVER SEAT MAIN GEARSHIFT CONTROL HANDLE ASSEMBLY MAIN GEARLEVER WELDMENT GEARBOX UPPER COVER GEARLEVER SPRING GEARLEVER SPRING GEARLEVER SPRING RETAINER RING AUXILIARY GAR GUIDE PLATE NUT MAIN GEARSHIFT GUIDE PLATE LOWER CONTROL ROD PIN PIN GEARLEVER DUSTPROOF BONNET ASSISTANT GEARLEVER WELDMENT ASSISTANT GEARLEVER WELDMENT GEARLEVER DUSTPROOF BONNET RETAINER RING NYLON SEAT 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0

09

TB50.7C- 7.. 变速箱操纵机构总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 7 9 GBT57-MX0-AL GBT9--A0P FT00A.7. 六角头螺栓 垫圈 变速杆定位销 GEARLEVER LOCATING PIN 0-_ 0-_ 0-_ 0

TB0.B-..- 后桥中央传动总成 - REAR AXLE CENTRAL TRANSMISSION ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 FT0..5 FT00..7 GBT9-0-A0P GBT57-0X0-AL GBT-M9X.5 小圆锥齿轮轴轴承座标准型弹簧垫圈六角头螺栓圆螺母 SMALL TAPER GEAR SHAFT BEARING SEAT ROUND NUT 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT5-9 FT00..a GBT79.-X50 GBT79.-X50 GBT79.-X50 圆螺母用止动垫圈啮合套弹性圆柱销弹性圆柱销弹性圆柱销 THRUST RING SHIFT COLLAR PIN PIN PIN 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT00..77 FT00..5 GBT-NUP0E FT00.. GBT57-0X5-AL 右差速器轴承座调整螺母圆柱滚子轴承左差速器轴承座六角头螺栓 RIGHT DIFFERENTIAL BEARING SEAT ADJUSTING NUT BEARING LEFT DIFFERENTIAL BEARING SEAT 0-_ 0-_ 00-0_ 0-_ 0-_ FT00.. GBT9--A0P TB55.-0 GBT9.-50 GBT9.- 锁片垫圈螺栓轴用弹性挡圈挡圈 LOCK SHIM SNAP RING RETAINER RING 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 FT0.G. GBT97-0 FT00.. FT00..9 FT00..0 前驱动输出齿轮圆锥滚子轴承锥齿轮轴调整垫片锥齿轮轴调整垫片锥齿轮轴调整垫片 FRONT DRIVE OUTPUT GEAR BEARING TAPER GEAR SHAFT ADJUSTING GASKET TAPER GEAR SHAFT ADJUSTING GASKET TAPER GEAR SHAFT ADJUSTING GASKET 0-_ 0-_ 0-_ 0-_ 0-_

TB0.B-..- 后桥中央传动总成 - REAR AXLE CENTRAL TRANSMISSION ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 0 FT00..0 GBT97-0 FT00.. FT00.. FT00.. 差速器总成圆锥滚子轴承短行星齿轮轴中心环左半轴齿轮 DIFFERENTIAL ASSEMBLY BEARING SHORT PLANETARY GEAR SHAFT CENTRAL RING LEFT HALF SHAFT GEAR 0-_ 00-0_ 0-_ 0-_ 0-_ 5 FT00..0 FT00.. FT00..5 FT00..09 FT00..09 差速器壳体大圆锥齿轮行星齿轮轴止推螺栓差速锁总成差速锁总成 DIFFERENTIAL HOUSING BIG TAPER GEAR PLANET GEAR SHAFT THRUST DIFFERENTIAL LOCK ASSEMBLY DIFFERENTIAL LOCK ASSEMBLY 0-_ 0-_ 0-_ 0-_ 0-_ 7 GBT97-0 FT00.. GBT70-M-AL FT00..5 FT00.. 圆锥滚子轴承大锥齿轮固定螺栓螺母锁紧垫片差速器盖 BEARING FIXING NUT LOCKING DIFFERENTIAL HOUSING 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 FT00.. FT00..7 FT00.. FT00.. FT00..5 差速器盖半轴齿轮垫片右半轴齿轮行星齿轮垫片行星齿轮 DIFFERENTIAL HOUSING HALF SHAFT GEAR RIGHT HALF SHAFT GEAR PLANET GEAR PLANETARY GEAR 0-_ 0-_ 0-_ 0-_ 0-_ 9 FT00..5 FT00.. 行星齿轮 长行星齿轮轴 PLANETARY GEAR LONG PLANETARY GEAR SHAFT 0-_ 0-_

5

TB55.A.- 差速锁操纵机构总成.-DIFFERENTIAL LOCK CONTROL MECHANISM ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT5.-5.0X.5G GBT79.-X5 GBT79.-.5X5 TB55.A. Q70 液压气动用 O 形橡胶密封圈弹性圆柱销弹性圆柱销差速锁踏杆焊合件碗形塞片 O-SEAL RING PIN PIN DIFFERENTIAL LOCK PEDAL LEVER WELDMENT PLUG PIECE 0-_ 0-_ 0-_ 00-0_ 0-_ 5 TB55.A. TB55.A. GBT9--A0P GBT57-MX5-.-AL FT00..5a 差速锁踏板焊合件差速锁上踏杆焊合件弹簧垫圈六角头螺栓差速锁拨叉轴 DIFFERENTIAL LOCK PEDAL WELDMENT DIFFERENTIAL LOCK PEDAL LEVER WELDMENT SPRING DIFFERENTIAL LOCK FORK SHAFT 00-0_ 00-0_ 0-_ 0-_ 0-_ 5 7 FT00..0 FT00..59a FT00..90 GBT79.-X0 GBT79.-.5X0 差速锁回位弹簧差速锁拨叉差速锁拨块弹簧圆柱销弹性圆柱销 DIFFERENTIAL LOCK RETURN SPRING DIFFERENTIAL LOCK FORK DIFFERENTIAL LOCK DIAL BLOCK SPRING COLUMN PIN PIN 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT57-MX5-AL GBT70-M-AL TB55.A. 六角头螺栓 螺母 差速锁下踏杆焊合件 NUT DIFFERENTIAL LOCK DOWN PEDAL WELDMENT 0-_ 0-_ 00-0_

7

FT00.9.00-9.- 最终传动总成 - 9FINAL TRANSMISSION ASSEMBLY - 标号 代号 数量 Quantity 备注 Remark 0 FT00.9.09 FT00.9.0 FT00.9. FT00.9. FT00.9.0 滚针外隔圈驱动轴锁片驱动轴锁紧螺栓挡块行星架 NEEDLE OUTER SPACER RING DRIVING SHAFT LOCK PIECE DRIVING SHAFT LOCK RETAINER BLOCK PLANET CARRIER 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 FT00.9. FT00.9. FT00.9. FT00.9. FT00.9. 调整垫片调整垫片调整垫片调整垫片隔套 ADJUSTING ADJUSTING ADJUSTING ADJUSTING SPACER BUSH 999 999 999 999 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 GBT7- FT00.9.5 FT00.9.0 GBT7- GBT977.-FB70X95X0D 深沟球轴承左驱动轴壳体行星轮球轴承内包骨架旋转轴唇形密封 BEARING LEFT DRIVING SHAFT HOUSING PLANET GEAR BALL BEARING O RING 0-_ 0-_ 0-_ 0-_ 0-_ 5 GBT5.-5X.55G FT00.9. GBT9--AOP GBT57-MX0-.-AL FT00.9. 液压气动用 O 形橡胶密封圈油封座垫圈六角头螺栓后轮毂螺栓 ( 左 ) O-SEAL RING OIL SEAL CAGE REAR HUB (LEFT) 00-0_ 0-_ 0-_ 0-_ 7 9 FT00.9. FT00.9.7 GBT7-MX.5-LH-0-AL GBT09-P5X.-G FT00.9.05 驱动轴垫圈 型六角螺母滚针滚针内隔圈 DRIVING SHAFT HEXAGON NUT, TYPE- NEEDLE NEEDLE INNER SPACER RING 0-_ 0-_ 00-0_ 0-_ 0-_

9

FT00.9.00-9.- 最终传动总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 7 9 GBT79.-5X GBT79.-X FT00.9.0 FT00.9.07 FT00.9.0 弹性圆柱销弹性圆柱销行星轮轴齿圈左半轴 PIN PIN PLANET GEAR SHAFT GEAR RING LEFT HALF SHAFT 0-_ 0-_ 0-_ 0-_ 0-_ 0

FT00.9.00-9.- 最终传动总成 - 9FINAL TRANSMISSION ASSEMBLY - 标号 代号 数量 Quantity 备注 Remark 0 GBT7-MX.5-LH-0-AL GBT7- FT00.9. GBT7- FT00.9. 型六角螺母球轴承右驱动轴壳体深沟球轴承隔套 HEXAGON NUT, TYPE- BALL BEARING RIGHT DRIVING SHAFT HOUSING BEARING SPACER BUSH 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 FT00.9. FT00.9. FT00.9. FT00.9. FT00.9.0 调整垫片调整垫片调整垫片调整垫片行星架 ADJUSTING ADJUSTING ADJUSTING ADJUSTING PLANET CARRIER 9999 9999 9999 9999 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT00.9. FT00.9. FT00.9.7 FT00.9.0 FT00.9.0 挡块驱动轴锁紧螺栓垫圈驱动轴锁片右半轴 RETAINER BLOCK DRIVING SHAFT LOCK DRIVING SHAFT LOCK PIECE RIGHT HALF SHAFT 0-_ 0-_ 0-_ 0-_ 0-_ 5 FT00.9.0 FT00.9.07 GBT79.-5X GBT79.-X FT00.9.0 右半轴齿圈弹性圆柱销弹性圆柱销行星轮轴 RIGHT HALF SHAFT GEAR RING PIN PIN PLANET GEAR SHAFT 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 FT00.9.09 FT00.9.0 GBT09-P5X.-G FT00.9.05 FT00.9. 滚针外隔圈行星轮滚针滚针内隔圈驱动轴 NEEDLE OUTER SPACER RING PLANET GEAR NEEDLE NEEDLE INNER SPACER RING DRIVING SHAFT 0-_ 0-_ 0-_ 0-_ 0-_

FT00.9.00-9.- 最终传动总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 7 FT00.9.5 GBT57-MX0-.-AL GBT9--AOP FT00.9. GBT5.-5X.55G 后轮毂螺栓六角头螺栓垫圈油封座液压气动用 O 形橡胶密封圈 REAR HUB OIL SEAL CAGE O-SEAL RING 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT977.-FB70X95X0D 内包骨架旋转轴唇形密封 O RING 0-_

5

TB50.0B- 0.- 全液压转向管路总成 - FULL HYDRAULIC STEERING PIPE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 GBT70-M0-AL GBT9--A0P FT50.0Y.0 FT50.0.05-MX.5 JBT9- 螺母垫圈油泵吸油钢管焊合件空心螺栓组合密封垫圈 NUT OIL PUMP INLET STEEL PIPE WELDMENT HOLLOW COMBINED SEAL GASKET 5 5 JBT9- GBT57-MX0-.-AL GBT5.-7.0X.5G GBT5.-.0X.5G FT5.0J.0 组合密封垫圈六角头螺栓液压气动用 O 形橡胶密封圈液压气动用 O 形橡胶密封圈恒流溢流泵 COMBINED SEAL GASKET O-SEAL RING O-SEAL RING PERMANENT OVERFLOW PUMP 0-_ 7 7 9 9 TB50.0B.7 TB50.0B.7a GBT77.-G TB50.0B.a TB50.0B. 输油钢管焊合输油钢管总成 7 直通接头体输油钢管焊合 输油钢管焊合 OIL CONVEYING PIPE WELDMENT OIL CONVEYING PIPE ASSEMBLY 7 STRAIGHT THREAD JOINT OIL CONVEYING PIPE WELDMENT OIL CONVEYING PIPE WELDMENT 0-_ 0-_ 0 0 GBT9-0-A0P TB50.0B. TB50.0B. TB50.0B. TH5.0- 标准型弹簧垫圈输油胶管总成 输油胶管总成输油胶管总成管接头 OIL CONVEYING HOSE ASSEMBLY OIL CONVEYING HOSE ASSEMBLY OIL CONVEYING HOSE ASSEMBLY PIPE JOINT 0-_ 5 JBT9-0 TB50.0B-0a TB50.0B-0 TG0.0F-0 GBT70-M-AL 组合密封垫圈油管支架 油管支架 孔管夹螺母 COMBINED SEAL GASKET OIL PIPE BRACKET OIL PIPE BRACKET THREE-HOLE PIPE CLAMP NUT 0-_

7

TB50.0B- 0.- 全液压转向管路总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 7 9 GBT57-MX5-.-AL GBT57-MX0-.-AL GBT97.--A0P TB50.0X-0 TB50.0B. 六角头螺栓六角头螺栓平垫圈转向油箱支架转向油箱支架焊合 STEERING OIL TANK BRACKET STEERING OIL TANK BRACKET WELDMENT 0-_ 5 7 GBT57-M0X5-.-AL FT5.0C.0 Q77 TB50.0-0 TB50.0B-0 六角头螺栓转向油箱及呼吸器总成软管环箍 7 回油软管吸油软管 STEERING OIL TANK AND BREATH ASSEMBLY HOSE HOOP 7 OIL RETURN HOSE OIL SUCTION HOSE 0-_ 9 FT00.0X.0 GBT57-MX0-.-AL 吸油软管 六角头螺栓 OIL SUCTION HOSE

9

TB50.0B 0.- 转向器及转向管柱总成 0.-REDIRECTOR OR STEERING COLUMN ASSEMBLY 标号 代号 数量 Quantity 备注 Remark... FT5.0C.0a FT5.0C.0a GBT7-MX.5-AL FT50.0.7 GBT9.-0 转向管柱总成转向管柱总成六角薄螺母轴承挡圈挡圈 0 STEERING PIPE COLUMN ASSEMBLY STEERING PIPE COLUMN ASSEMBLY NUT BEARING RETAINER RING BLCOKING RING 0-_ 0-_ 0-_..5..7. GBT7-0-LS FT50.0.7 GBT9.- FT5.0C.0a FT5.0C.00 轴承轴承挡圈 档圈转向杆转向套管焊合 BEARING BEARING RETAINER RING RETAINER RING STEERING ROD STEERING SLEEVE WELDMENT 0-_ 0-_ 0-_ 009-_ 0-_ 5 FT00.0.0 TB50.0-0 TB50.0-0 GBT57-M0X0-.-AL GBT9-0-A0P 转向盘总成转向杆防护套转向杆防护套六角头螺栓标准型弹簧垫圈 STEERING WHEEL ASSEMBLY STEERING ROD SHIELD SLEEVE STEERING ROD SHIELD SLEEVE 0-_ 0-_ 0-_ 0-_ 0-_ FT5.0C.05 FT5.0C.05 液压转向器总成 液压转向器总成 HYDRAULIC STEERING MECHANISM ASSEMBLY HYDRAULIC STEERING MECHANISM ASSEMBLY 0-_ 0-_ 0

TB50.0B- 0.- 全液压转向管路总成 - FULL HYDRAULIC STEERING PIPE ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 GBT57-M0X0-.-AL GBT57-M0X0-.-AL TB50.0B.0 JBT9- TB50.0B.5 六角头螺栓六角头螺栓卡套式组合直角管接头组合密封垫圈输油胶管总成 JOINT COMBINED SEAL GASKET OIL CONVEYING HOSE ASSEMBLY 5 GBT77.-G TB50.0B. TB50.0B.a TB50.0B. JBT9-0 直通接头体输油钢管总成输油钢管总成 输油胶管总成组合密封垫圈 STRAIGHT THREAD JOINT OIL CONVEYING PIPE ASSEMBLY OIL CONVEYING PIPE ASSEMBLY OIL CONVEYING HOSE ASSEMBLY COMBINED SEAL GASKET 0-_ 7 9 0 TH5.0- TB50.0B.9 TG0.0E-0 GBT9-0-A0P GBT57-MX5-.-AL 管接头输油胶管总成双孔管夹标准型弹簧垫圈六角头螺栓 PIPE JOINT OIL CONVEYING HOSE ASSEMBLY DOUBLE-HOLE PIPE CLIP TB50.0B.a TB50.0B. GBT70-M--AL GBT97.-0-A0P GBT57-MX0-.-AL 输油钢管总成 输油钢管总成 Ⅰ 型六角螺母平垫圈六角头螺栓 OIL CONVEYING PIPE ASSEMBLY OIL CONVEYING PIPE ASSEMBLY I-TYPE HEXAGON NUT 0-_ 5 7 9 TG5.0-07 TB50.0-0 GBT9--A0P GBT70-M-AL GBT7.-G 单孔管夹油管支架 Ⅲ 垫圈螺母卡套式端直通接头体 SINGLE HOLE PIPE CLAMP OIL PIPE BRACKET NUT STRAIGHT PIPE JOINT BODY

TB00.D.- 动力输出齿轮总成.-PTO GEAR ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT9.-0 FT00.. GBT7-0 FT00.C. FT00.E.05 挡圈 0 垫圈深沟球轴承输出轴前挡环动力输出被动小齿轮 0 BEARING OUTPUT SHAFT FRONT RETAINER RING PTO DRIVEN SMALL GEAR 0-_ 0-_ 0-_ 0-_ 0-_ 5 5 7 JBT79-K5X0X7 FT00.C.7 FT00.C.7 FT00.C. FT00.E.0 向心滚针和保持架组件动力输出啮合座动力输出啮合座动力输出啮合套动力输出被动大齿轮 NEEDLE AND CARRIER UNIT PTO MESHING SEAT PTO MESHING SEAT PTO SHIFT COLLAR PTO DRIVEN BIG GEAR 0-_ 0-_ 0-_ 0-_ 0-_ 9 0 FT00.E. GBT7-0 FT00.E.9 GBT7-09 FT00.E. 后挡环深沟球轴承输出轴半挡环深沟球轴承输出轴轴承垫圈 REAR RETAINER RING BEARING OUTPUT SHAFT HALF RETAINER RING BEARING OUTPUT SHAFT BEARING 0-_ 0-_ 0-0_ 0-_ 0-_ 5 7 GBT977.-FB50X7XD FT00.E.5 FT00.E.0 GBT9--AOP GBT57-MX55 内包骨架旋转轴唇形密封油封挡圈后端盖 Ⅰ 垫圈六角头螺栓 O RING OIL SEAL RETAINER RING REAR END COVER I 0-_ 0-_ 0-_ 0-_ 00-0_ 9 GBT57-MX5-AL FT00..a FT00.E.0 FT00.E.0 FT00.E. 六角头螺栓安全防护罩动力输出高档主动齿轮动力输出高档主动齿轮隔套 SAFTY BONNET PTO HIGH GEAR DRIVING GEAR PTO HIGH GEAR DRIVING GEAR SPACER BUSH 0-_ 0-_ 0-_ 0-_ 0-_

5

TB00.D.- 动力输出齿轮总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 5 7 FT00.E.0 FT00.E.0 GBT7-0N GBT05-90-9.5 GBT-M5X.5 动力输出低档主动齿轮动力输出低档主动齿轮深沟球轴承止动环圆螺母 PTO LOW GEAR DRIVING GEAR PTO LOW GEAR DRIVING GEAR BEARING THRUST RING ROUND NUT 0-_ 0-_ 0-_ 0-_ 0-_ 9 GBT5-5 止退垫圈 LOCK 0-_

7

TB550.A.- 动力输出轴总成.-PTO SHAFT ASSEMBLY 标号 代号 数量 Quantity 备注 Remark TB550.A-0 TB550.A-0 TE50.C-0 FT00.E.0 GBT9-0 Ⅰ5 型动力输出轴 Ⅰ5 型动力输出轴动力输出轴护罩动力输出轴盖垫圈 0 TYPE-I 5 PTO SHAFT TYPE-I 5 PTO SHAFT PTO SHAFT HOOD PTO SHAFT COVER 0 0-_ 0-_ 00-_ 00-0_ 0-_ GBT57-0X0-AL 六角头螺栓 0-_

9

TB550.D.- 动力输出操纵总成.-PTO CONTROL ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 FT00..05 GBT9- TB550.-0 GBT97.-0-A0P GBT9-.X-A0P 动力输出操纵手柄总成垫圈螺栓平垫圈开口销 PTO CONTROL HANDLE ASSEMBLY PIN 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 GBT9-.5X-A0P TB550.-0 FT70.B. GBT0-9.5-G00-b TB550.-0 开口销螺钉拨叉轴定位弹簧钢球指形拨杆焊合件 PIN SCREW FORK SHAFT LOCATING SPRING BALL FINGER LEVER WELDMENT 0-_ 0-_ 0-_ 0-_ 0-05_ 9 9 0 FT00.E.0 GBT5.-.X.5G GBT5.-.0X.5G GBT70-M0-AL FT00.E.09 指形拨杆焊合件液压气动用 O 形橡胶密封圈液压气动用 O 形橡胶密封圈螺母拨杆轴套 FINGER LEVER WELDMENT O-SEAL RING O-SEAL RING NUT LEVER SHAFT SLEEVE 00-0_ 0-_ 0-_ 5 GBT9--AOP GBT57-MX0-AL FT00..0 GBT79.-X GBT79.-.5X 弹簧垫圈螺栓动力输出变速杆焊合件弹性圆柱销弹性圆柱销 SPRING PTO GEARSHIFT LEVER WELDMENT PIN PIN 0-_ 0-_ 0-_ 0-_ 0-_ 7 TB550.-0a FT00.C.07a TB550.D. TB550.D. TB550.D. 动力输出变速拨叉动力输出拨叉轴动力输出操纵连接杆总成动力输出操纵手柄杆焊合动力输出操纵手柄杆焊合 PTO GEARSHIFT FORK PTO FORK SHAFT PTO CONTROL CONNECTING LEVER ASSEMBLY PTO CONTROL HANDLE LEVER WELDMENT PTO CONTROL HANDLE LEVER WELDMENT 0-_ 0-_ 0-_ 0-_ 0-_ 0

TB550.D.- 动力输出操纵总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 7 FT00.. GBT-B0X0 FT00..0 FT00.E. FT00..0 隔套销轴拉杆前叉操纵杆轴套 SPACER BUSH PIN PULL ROD FRONT FORK CONTROL ROD SHAFT SLEEVE 0-_ 0-_ 0-_ 0-_ 0-_ 9 FT00..9 垫圈 0-_

TB55.C.- 分动箱箱体总成.-TRANSFER CASE HOUSING ASSEMBLY 标号 代号 数量 Quantity 备注 Remark... TB55.C. TB55.C. FT0..7 FT0..7 FT0..0 分动箱装配总成分动箱装配总成轴承盖轴承盖惰轮轴 TRANSFER CASE INSTALLATION ASSEMBLY TRANSFER CASE INSTALLATION ASSEMBLY BEARING COVER BEARING COVER IDLER SHAFT 0-_ 0-_ 0-_ 0-_ 0-_.....5 GBT9--AOP GBT57-MX0-AL GBT5.-7.0X.0G TB55.E.. TB55.B-0 弹簧垫圈螺栓液压气动用 O 形橡胶密封圈转轴焊合转轴隔套 SPRING O-SEAL RING ROTARY SHAFT WELDMENT ROTARY SHAFT SPACER BUSH 0-_ 0-_ 0-_ 0-_ 0-_..7..9.9 TB55.E.-05 GBT9-0-A0P GBT57-M0X5-AL FT0.F.9 TB55.E.-0 侧盖标准型弹簧垫圈六角头螺栓分动箱拨叉轴拨叉轴 SIDE COVER TRANSFER CASE FORK SHAFT FORK SHAFT 0-_ 0-_ 0-_ 007-0_..... FT0.F.0 GBT79.-X0 GBT79.-.5X0 GBT0-0-G00-b FT00.7.9 止推环弹性圆柱销弹性圆柱销钢球弹簧 PLATE;THRUST PIN PIN BALL SPRING 0-_ 0-_ 0-_ 0-_ 009-_...5.5. FT0..5 TB55.E.-0 JBT9- JBT9- FT0..0 弹簧分离拨叉组合密封垫圈组合密封垫圈螺堵 SPRING RELEASE SHIFT FORK COMBINED SEAL GASKET COMBINED SEAL GASKET SCREW PLUG 00-0_ 0-_ 0-_ 0-_ 0-_

5

TB55.C.- 分动箱箱体总成 ( 续 ) 标号 代号 数量 Quantity 备注 Remark.7..9.. FT0.F.05 TB55.C.-0 GBT977.-FB0X5X7D FT0.F.0 JBT79-K5XX0 分动箱输出轴分动箱被动齿轮内包骨架旋转轴唇形密封轴承座向心滚针和保持架组件 TRANSFER CASE OUTPUT SHAFT TRANSFER CASE DRIVEN GEAR O RING BEARING SEAT NEEDLE AND CARRIER UNIT 0-_ 0-_ 0-_ 0-_ 0-_..5...7 FT0.. FT0.F.5 FT0.F.0 FT0.F.0a FT0.. 滚针内隔套分动箱惰轮分动箱箱体分动箱箱体止动螺钉 NEEDLE INNER SPACER SLEEVE TRANSFER CASE IDLER TRANSFER CASE BODY TRANSFER CASE BODY THRUST SCREW 0-_ 0-_ 007-0_ 0-_..9 GBT7-M0X-AL GBT7-0 GBT5.-X.55G GBT9-0-A0P GBT57-M0X0-.-AL 六角薄螺母深沟球轴承液压气动用 O 形橡胶密封圈标准型弹簧垫圈六角头螺栓 NUT BEARING O-SEAL RING 0-_ 0-_ 0-_ 0-_ 009-05_ GBT57-M0X5-AL 螺栓 00-0_

7

TB5..- 分动箱传动总成.-TRANSFER CASE TRANSMISSION ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 GBT9--AOP GBT9.- FT0.X.07 GBT57-MX0-AL TB55.. 弹簧垫圈轴用弹性挡圈护套 () 焊合件螺栓中间轴承座总成 SPRING SNAP RING GUARD SLEEVE WELDMENT () MIDDLE BEARING SEAT ASSEMBLY 0-_ 0-_ 0-_ 0-_ 0-_.....5 GBT9.-7 FT0.X. GBT7-007-RZ FT0.X.7 FT0.X. 孔用弹性挡圈隔圈深沟球轴承橡胶圈中间轴承座 SNAP RING BEARING RUBBER RING MIDDLE BEARING SEAT 0-_ 0-_ 0-_ 0-_ 0-_..7 5 GBT9.-mX0-A0P FT0.X.5 GBT9--AOP GBT57-MX0-AL FT0..9 圆柱销中间花键套垫圈螺栓前传动轴 PIN MIDDLE SPLINE BUSH FRONT TRANSMISSION SHAFT 007-0_ 0-_ 0-_ 0-_ 0-_ 7 7 FT0..0 FT0..0 GBT57-MX-AL FT0.F.05 GBT9-0-A0P 护套 () 焊合件护套 () 焊合件螺栓护罩 () 焊合件标准型弹簧垫圈 GUARD SLEEVE WELDMENT () GUARD SLEEVE WELDMENT () BONNET () WELDMENT 0-_ 0-_ 0-_ 0-_ 0-_ 5 7 9 GBT57-M0X0-AL GBT5.-.5X.55G GBT79.-X5 FT0..07a FT0.. 螺栓液压气动用 O 形橡胶密封圈弹性圆柱销花键套后传动轴 O-SEAL RING PIN SPLINE BUSH REAR TRANSMISSION SHAFT 0-_ 0-_ 0-_ 0-_ 0-_

9

TB55.C.- 分动箱操纵总成.-TRANSFER CASE CONTROL ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 FT5..05 TB55.C-0 GBT70-M0-AL TG0.5. FT0.D.7 拉压手柄摇臂螺母密封胶圈密封胶圈 PULL/PRESS HANDLE ROCKER NUT SEAL RUBBER RING SEAL RUBBER RING 0-_ 0-_ 0-_ 00-0_ 0-_ 5 7 FT0.D.0 TB55.B. GBT-B0X0 GBT97.-0-A0P GBT9-.X-A0P 操纵杆合件操纵杆合件销轴平垫圈开口销 CONTROL ROD UNIT CONTROL ROD UNIT PIN PIN 00-0_ 00-0_ 0-_ 0-_ 0-_ 9 GBT79.-5X GBT79.-X 弹性圆柱销 弹性圆柱销 PIN PIN 0-_ 0-_ 50

5

TB50..- 左制动器总成.-LEFT BRAKE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 0. 0. FT00..0 FT00..0 FT00.. FT00.. FT00..0 碗形塞左制动器壳总成曲柄轴衬套左制动器壳拨块 BOWL PLUG LEFT BRAKE HOUSING ASSEMBLY CRANK SHAFT BUSH LEFT BRAKE HOUSING SHIFTING BLOCK 0-_ 0-_ 0-_ 0-_ 5 5 5 7 9 FT00..07 GBT5.-0.0X.5G TB50.. TB50.. FT00..5 JBT9- FT00..5 GBT0-.000-G00-b FT00..0 FT00..0 FT00..05 FT00..0 GBT9.- FT00..09a GBT5.-.0X.5 隔套液压气动用 O 形橡胶密封圈左曲柄合件左曲柄合件最终传动放油口垫圈组合密封垫圈螺塞钢球左制动器压盘制动器摩擦盘总成隔板 O 形圈挡圈垫圈 O 形圈 SPACER BUSH O-SEAL RING LEFT CRANK UNIT LEFT CRANK UNIT FINAL TRANSMISSION OIL DRAINING PORT COMBINED SEAL GASKET SCREW PLUG BALL LEFT BRAKE PRESSURE PLATE BRAKE FRICTION PLATE ASSEMBLY SPACER PLATE O-RING RETAINER RING O-RING 0-_ 0-_ 0-_ 0-_ 0-_ 0-0_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 5

5

TB50..- 右制动器总成.-RIGHT BRAKE ASSEMBLY 标号 代号 数量 Quantity 备注 Remark 0 TB50.. FT00..5 FT00..0 FT00..0 FT00..05 右曲柄合件螺塞 O 形圈制动器摩擦盘总成隔板 RIGHT CRANK UNIT SCREW PLUG O-RING BRAKE FRICTION PLATE ASSEMBLY SPACER PLATE 0-_ 0-_ 0-_ 0-_ 0-_ 5 FT00..0 GBT0-.000-G00-b FT00..0 GBT5.-0.0X.5 FT00..07 右制动器压盘钢球碗形塞 o 型圈隔套 RIGHT BRAKE PLATEN BALL BOWL PLUG O.RING SPACER BUSH 0-_ 0-_ 0-_ 0-_ 0-_ 5 5. 5. FT00..0 FT00..0 FT00.. FT00.. GBT5.-0.0.5 拨块右制动器壳总成右制动器壳曲柄轴衬套 O 型圈 SHIFTING BLOCK RIGHT BRAKE HOUSING ASSEMBLY RIGHT BRAKE HOUSING CRANK SHAFT BUSH O-RING 0-_ 0-_ 0-_ 0-_ 0-_ 7 9 9 FT00..09a GBT9.- JBT9- FT00..5 垫圈挡圈组合密封垫圈最终传动放油口垫圈 RETAINER RING COMBINED SEAL GASKET FINAL TRANSMISSION OIL DRAINING PORT 0-_ 0-_ 0-0_ 0-_ 5

55

TB50.-..- 制动器操纵机构总成 - BRAKE CONTROL MECHANISM ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 GBT-B0X-A0P FT00..0 TB50.. TB50.. GBT79.-X0 销轴踏板回位弹簧右制动踏板体合件左制动踏板合件弹簧圆柱销 PIN PEDAL RETURN SPRING RIGHT BRAKE PEDAL BODY UNIT LEFT BRAKE PEDAL UNIT SPRING COLUMN PIN 0-_ 0-_ 0-_ 5 7 GBT79.-0X0 FT00..00a GBT79.-X0 TB50..0 TB50... 弹性圆柱销踏板轴合件弹性圆柱销左制动踏板体焊合右制动踏板体焊合 PIN PEDAL SHAFT UNIT PIN LEFT BRAKE PEDAL BODY WELDMENT RIGHT BRAKE PEDAL BODY WELDMENT 0-_ 0-_ 0-_ 5 5 FT00..0 GBT97.-0-A0P GBT9-.X-A0P TB50.-07 FT00..0 拉杆后叉平垫圈开口销拉杆拉杆 PULL ROD REAR FORK PIN PULL ROD PULL ROD 0-_ 0-_ 0-_ 00-0_ 00-0_ 7 7 9 GBT70-M0-AL FT00..0 TA700.A-0 GBT9.-5 GBT97.--A0P 螺母拉杆前叉右旋长条孔连接叉挡圈垫圈 NUT PULL ROD FRONT FORK DEXTROROTATION LONG HOLE CONNECT FORK RETAINER RING 0-_ 009-0_ 0-_ 0-_ 9 GBT97.--A0P 垫圈 0-_ 5

57

TB50.-..- 制动器操纵机构总成 - BRAKE CONTROL MECHANISM ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark.... TA0.D. TA0.D.. GBT57-MX0-AL GBT9--A0P GBT70-M-AL 手刹把手总成手刹把手六角头螺栓垫圈螺母 HAND BRAKE HANDLE ASSEMBLY HAND BRAKE HANDLE NUT 0-_ 0-_ 0-_ 0 0 0. 0. 5 7 9 0 TB50..7 TB50..7 TB50..7. GBT7-MX-05-AL GBT97.-0-A0P GBT9-.X-A0P TE50.C- TB50.-09 TB50.-0 GBT-B0X-A0P TB50..5 TB50.. GBT57-MX5-AL GBT-B0X-A0P GBT-B0X0-A0P TE50.C- TB50.. GBT97.-0-A0P GBT97.-0-A0P GBT9.-0 左制动拉线装配总成左制动拉线装配总成左制动拉线总成六角薄螺母平垫圈开口销制动拉线上固定板制动曲柄回位弹簧制动曲柄回位弹簧销轴右制动过渡轴套合件右制动过渡转轴焊合螺栓销轴销轴连接叉右制动中间拉杆焊合垫圈垫圈挡圈 0 PULL WIRE INSTALLATION ASSEMBLY OF LEFT BRAKE PULL WIRE INSTALLATION ASSEMBLY OF LEFT BRAKE LEFT BRAKE WIRE ASSEMBLY NUT PIN UPPER FIXING PLATE OF BRAKE PULL WIRE BRAKE CRANK RETURN SPRING BRAKE CRANK RETURN SPRING PIN TRANSITION SHAFT SLEEVE UNIT OF RIGHT BRAKE TRANSITION ROTARY SHAFT WELDMENT OF RIGHT BRAKE PIN PIN CONNECTING ROD FORK 5 5 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 00-0_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 0-_ 5

59

TB50.-..- 制动器操纵机构总成 -( 续 ) 标号 代号 数量 Quantity 备注 Remark 5 5 FT00A.B.9 GBT70-M0-LH-AL GBT70-M-AL GBT9--A0P TA0.D. 左旋拉杆叉螺母螺母垫圈棘轮支架焊合 LEFT REVOLVING PULL ROD FORK NUT NUT RATCHET WHEEL BRACKET WELDMENT 0-_ 0-_ 0-_ 0-_ 7 9 GBT57-M0X5-AL GBT9-0-A0P GBT57-M 5-AL TB50.. 螺栓标准型弹簧垫圈螺栓右制动拉线装配总成 PULL WIRE INSTALLATION ASSEMBLY OF RIGHT BRAKE 0-_ 0-_ 0-_ 0

TB00.G - 座椅安装总成 SEAT INSTALLATION ASSEMBLY 标号 代号 数量 Quantity 备注 Remark GBT57-M0X0-.-AL GBT57-M0X0-.-AL GBT9-0-A0P FT00.B.00 TB00.G. 六角头螺栓六角头螺栓标准型弹簧垫圈座椅总成座椅总成 SEAT ASSEMBLY SEAT ASSEMBLY 0-_ 0-0_

TB550.5Y 5.- 地板总成 5.-FLOOR ASSEMBLY 标号 代号 数量 Quantity 备注 Remark TB550.5Y- TB550.5Y- TB550.5Y- 地板总成 - 地板总成 - 地板总成 - FLOOR ASSEMBLY- FLOOR ASSEMBLY- FLOOR ASSEMBLY- 0-05_ 0-05_ 0-05_

5

TB550.5U- 5..- 地板总成 - FLOOR ASSEMBLY- 标号 代号 数量 Quantity 备注 Remark 0 GBT57-MX-.-AL TA700.5B-0 TA700.5B-0 GBT9-5-A0P GBT57-M5X-.-AL 六角头螺栓塑铸螺母橡胶垫圈标准型弹簧垫圈六角头螺栓 CAST NUT RUBBER 5 7 GBT57-MX5-.-AL TB550.5J. GBT9--A0P GBT70-M--AL TB550.5J. 六角头螺栓后视镜支架焊合垫圈 Ⅰ 型六角螺母地板焊合 REAR VIEW MIRROR BRACKET WELDMENT I-TYPE HEXAGON NUT FLOOR WELDMENT 5 GBT9--A0P GBT97.--A0P TB00.5L-0 TB00.5L-9 TB00.5A. 弹簧垫圈平垫圈仪表台总成仪表台密封条后视镜总成 SPRING DASHBOARD ASSEMBLY DASHBOARD SEAL STRIP REARVIEW MIRROR ASSEMBLY 7 7 9 TB550.5J.5 TB550.5J.5 TB00B.7-0 TB550.5J-0 右支架焊合右支架焊合机罩气弹簧前挡风玻璃 RIGHT BRACKET WELDMENT RIGHT BRACKET WELDMENT BONNET PNEUMATIC SPRING FRONT WINDSHIELD